Eric, CR426...I can find it in the MTT module but can't read the part number. Part looks like a zener diode, could you please confirm this. David Lessard, Alexandria, Ontario, mr_fixit@xxxxxxxxxxxx ----- Original Message ----- From: "Eric Manuel" <tvman@xxxxxxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Friday, October 14, 2005 4:58 PM Subject: [TechAssist] Re: [TechAssit] RCA - 27" TV - PMR623ER - CTC130A - Dead - Shorted HOT > David check this out..Eric > > CTC130A DEAD LEAKY CR625 IN MTT002B TUNER CONTROL MODULE > > > Eric > E M Electronics > 59 Wights Rd > Deer Lake NL > Canada > A8A 2J2 > Ph# 709 635 2627 > tvman@xxxxxxxxxxxxxxx > > > > > > David Lessard wrote: > > Follow-up: > > > > Replaced HOT, and R426 horizontal drive +B, resistor value was up by > > 800ohms. TV pulses ON/OFF when ON" button is pressed, TV comes on for a > > brief second as power cord is unplugged. I've replaced C672, C654 and C656. > > When I disconnect RED wire on standup board next to VIPUR TV pulses ON/OFF. > > What am I missing? What are the start conditions for this chassis to > > fire-up? I know nothing about this 25 year old chassis. Thanks in advance. > > David Lessard, Alexandria, Ontario. mr_fixit@xxxxxxxxxxxx > > > > ----- Original Message ----- > > From: "Phil Bader" <tjanphyl@xxxxxxxxxxxxxxx> > > To: <techassist@xxxxxxxxxxxxx> > > Sent: Monday, October 03, 2005 9:57 PM > > Subject: [TechAssist] Re: [TechAssit] RCA - 27" TV - PMR623ER - CTC130A - > > Dead - Shorted HOT > > > > > > > >>Yes. > >>Dead,5A fuse blown. Fix: Shorted cap C425 (043uf@200V) yoke return I > > > > think. > > > >>After you get it on, here's some issues you may face: > >>Brightness a bit exessive,retrace: C122 (30uf@250V) front of flyback. > >>Raster narrow at sides, slight bow: Q1 on pincushion upright board near > >>rear of chassis. RCA#146847/2N2222A,checks OK-replace it. > >>Channels 2-6OK, no 7-13. Open and resolder all stakes inside the MTT001 > >>module. > >>Bands of interference (two) slowely moving up thru picture.: Inside the > >>MTT001A, change C654(100uf/16v),C672(220uf/25V),C656(330uf/10V). > >>Immediate shut down at turn on:Flyback bad. > >>Vert. retrace at top inch of screen.All assoc. caps seem to ESR OK. > >>R506(6800ohm/2W) runs hot normally.Remove,scrape leads and resolder. > >>Left side jailbars: Workaround: Add a 10uf/250V cap across CRT's PC > >>board's stakes, pos. to "C6", neg to "Z1".(saves pulling chassis) > >>Excess brightness: C122 (47uf@250) > >>Unusual brightness issue: Increase brightness with control,all sudden at > >>max: R721 (680ohm) increased to 690ohm. Also: Q703 shorts > >>(#143806/NTE159).HTH. > >>Phil > >> > >>Philip Bader > >>Jan Phyl TV Inc. (estab. 1976) > >>3420 Recker Hwy. Winter Haven, Fl. 33880 > >>Fax (863) 299-8821 > >>email: tjanphyl@xxxxxxxxxxxxxxx > >>personal/ alt. email: pbader@xxxxxxxxxxxxxxx > >>see our ad at: > >> > > > > http://jan-phyl-television-pc-monitor-service.9601288257006.worldpages-ads.c > > om/ > > > >> > >> > >>David Lessard wrote: > >> > >> > >>>This TV has a shorted HOT (C1308K), main fuse is blown. Are there any > > > > common problems besides a bad flyback which could cause this? > > > >>>Thanks in advance, > >>>David Lessard > >>>Alexandria, Ontario, Canada > >>>mr_fixit@xxxxxxxxxxxx > >> > >>-------------------------------------------------------------------------- - > > > > -- > > > >>>This Email List is accessible to the general public through search > > > > engines. Remove: http://www.tech-assist.org/remove.htm > > > >>>Set Vacation > > > > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > > > >>>Lost Password: http://www.tech-assist.org and select "Login Problems?". > >>>Email Archives: //www.freelists.org/archives/techassist/ > >>> > >>> > >>> > >>> > >> > >>-------------------------------------------------------------------------- > > > > --- > > > >>This Email List is accessible to the general public through search > > > > engines. Remove: http://www.tech-assist.org/remove.htm > > > >>Set Vacation > > > > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > > > >>Lost Password: http://www.tech-assist.org and select "Login Problems?". > >>Email Archives: //www.freelists.org/archives/techassist/ > >> > > > > > > -------------------------------------------------------------------------- --- > > This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm > > Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > > Lost Password: http://www.tech-assist.org and select "Login Problems?". > > Email Archives: //www.freelists.org/archives/techassist/ > > > -------------------------------------------------------------------------- --- > This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm > Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > Lost Password: http://www.tech-assist.org and select "Login Problems?". > Email Archives: //www.freelists.org/archives/techassist/ > ----------------------------------------------------------------------------- This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/