[TechAssist] Re: [TechAssit] RCA - 27" TV - PMR623ER - CTC130A - Dead - Shorted HOT
- From: "John Conti" <contitv@xxxxxxxxxxx>
- To: techassist@xxxxxxxxxxxxx
- Date: Fri, 14 Oct 2005 16:14:33 -0500
David, just a few things to check,c115 (68uf) check r 115(36k)
cr105,cr408....also check r16 (1.5 ohm)p/n 175331 in the drain terminal of
Q1 VIR out for increase in value. This is a critical resistor. also c7
(68uf) c11 (150uf) can cause this problem. And c 108 (.22uf) Hope this
might help.
Also if that does't help check all solder connections on the mtt001 or 002
module.
John
Conti,sTV
Texas
>From: "David Lessard" <mr_fixit@xxxxxxxxxxxx>
>Reply-To: techassist@xxxxxxxxxxxxx
>To: <techassist@xxxxxxxxxxxxx>
>Subject: [TechAssist] Re: [TechAssit] RCA - 27" TV - PMR623ER - CTC130A -
>Dead - Shorted HOT
>Date: Fri, 14 Oct 2005 15:24:09 -0400
>
>Follow-up:
>
>Replaced HOT, and R426 horizontal drive +B, resistor value was up by
>800ohms. TV pulses ON/OFF when ON" button is pressed, TV comes on for a
>brief second as power cord is unplugged. I've replaced C672, C654 and C656.
>When I disconnect RED wire on standup board next to VIPUR TV pulses ON/OFF.
>What am I missing? What are the start conditions for this chassis to
>fire-up? I know nothing about this 25 year old chassis. Thanks in advance.
>David Lessard, Alexandria, Ontario. mr_fixit@xxxxxxxxxxxx
>
>----- Original Message -----
>From: "Phil Bader" <tjanphyl@xxxxxxxxxxxxxxx>
>To: <techassist@xxxxxxxxxxxxx>
>Sent: Monday, October 03, 2005 9:57 PM
>Subject: [TechAssist] Re: [TechAssit] RCA - 27" TV - PMR623ER - CTC130A -
>Dead - Shorted HOT
>
>
> > Yes.
> > Dead,5A fuse blown. Fix: Shorted cap C425 (043uf@200V) yoke return I
>think.
> >
> > After you get it on, here's some issues you may face:
> > Brightness a bit exessive,retrace: C122 (30uf@250V) front of flyback.
> > Raster narrow at sides, slight bow: Q1 on pincushion upright board near
> > rear of chassis. RCA#146847/2N2222A,checks OK-replace it.
> > Channels 2-6OK, no 7-13. Open and resolder all stakes inside the MTT001
> > module.
> > Bands of interference (two) slowely moving up thru picture.: Inside the
> > MTT001A, change C654(100uf/16v),C672(220uf/25V),C656(330uf/10V).
> > Immediate shut down at turn on:Flyback bad.
> > Vert. retrace at top inch of screen.All assoc. caps seem to ESR OK.
> > R506(6800ohm/2W) runs hot normally.Remove,scrape leads and resolder.
> > Left side jailbars: Workaround: Add a 10uf/250V cap across CRT's PC
> > board's stakes, pos. to "C6", neg to "Z1".(saves pulling chassis)
> > Excess brightness: C122 (47uf@250)
> > Unusual brightness issue: Increase brightness with control,all sudden at
> > max: R721 (680ohm) increased to 690ohm. Also: Q703 shorts
> > (#143806/NTE159).HTH.
> > Phil
> >
> > Philip Bader
> > Jan Phyl TV Inc. (estab. 1976)
> > 3420 Recker Hwy. Winter Haven, Fl. 33880
> > Fax (863) 299-8821
> > email: tjanphyl@xxxxxxxxxxxxxxx
> > personal/ alt. email: pbader@xxxxxxxxxxxxxxx
> > see our ad at:
> >
>http://jan-phyl-television-pc-monitor-service.9601288257006.worldpages-ads.c
>om/
> >
> >
> >
> > David Lessard wrote:
> >
> > >This TV has a shorted HOT (C1308K), main fuse is blown. Are there any
>common problems besides a bad flyback which could cause this?
> > >Thanks in advance,
> > >David Lessard
> > >Alexandria, Ontario, Canada
> > >mr_fixit@xxxxxxxxxxxx
> >
> >---------------------------------------------------------------------------
>--
> > >This Email List is accessible to the general public through search
>engines. Remove: http://www.tech-assist.org/remove.htm
> > >Set Vacation
>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation
> > >Lost Password: http://www.tech-assist.org and select "Login
>Problems?".
> > >Email Archives: //www.freelists.org/archives/techassist/
> > >
> > >
> > >
> > >
> >
>--------------------------------------------------------------------------
>---
> > This Email List is accessible to the general public through search
>engines. Remove: http://www.tech-assist.org/remove.htm
> > Set Vacation
>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation
> > Lost Password: http://www.tech-assist.org and select "Login Problems?".
> > Email Archives: //www.freelists.org/archives/techassist/
> >
>
>-----------------------------------------------------------------------------
>This Email List is accessible to the general public through search engines.
>Remove: http://www.tech-assist.org/remove.htm
>Set Vacation
>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation
>Lost Password: http://www.tech-assist.org and select "Login Problems?".
>Email Archives: //www.freelists.org/archives/techassist/
_________________________________________________________________
Don?t just search. Find. Check out the new MSN Search!
http://search.msn.click-url.com/go/onm00200636ave/direct/01/
-----------------------------------------------------------------------------
This Email List is accessible to the general public through search engines.
Remove: http://www.tech-assist.org/remove.htm
Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation
Lost Password: http://www.tech-assist.org and select "Login Problems?".
Email Archives: //www.freelists.org/archives/techassist/
Other related posts:
