But you still found it with the hunt and peck method which costs both you and your customer money. Using your scope would have narrowed that down to 15 minutes or so while the trouble was in progress. I have been telling guys for years to be a Tech not a tinkerer. Hollis Bates, Field Engineer retired USE YOUR SCOPE In a message dated 12/9/02 6:00:01 AM Eastern Standard Time, mrfixit@xxxxxxxxxxx writes: > Subj:[TechAssist] Re: GE 20GT425 Turns OFF/ON Repeatedly > Date:12/9/02 6:00:01 AM Eastern Standard Time > From:<A HREF="mailto:mrfixit@xxxxxxxxxxx";>mrfixit@xxxxxxxxxxx</A> > Reply-to:<A > HREF="mailto:techassist@xxxxxxxxxxxxx";>techassist@xxxxxxxxxxxxx</A> > To:<A HREF="mailto:techassist@xxxxxxxxxxxxx";>techassist@xxxxxxxxxxxxx</A> > Sent from the Internet > > > > > Symptom: > > Cyclic OFF/ON problem (relay clicking) usually after power-up but also > occured intermittently. The cycle can be stopped by holding the power > button > ON during the next OFF/ON cycle, then the TV shuts off normally. The > problem > was intermittent, sometimes days between acting up. > > Solution: > > Found numerous postings regarding CR4118, replaced it. No change. Confirmed > switch was not the problem by replacing it with another one. No change. > Re-soldered in and around HOT area, transformers, etc. No change. Further > investigation revealed several cold solder joints near R118U - 33ohm power > resistor near CR4118. Visual inpection didn't reveal this problem, the > joints appeared OK. The problem was discovered by applying pressure to the > PCB near R118U. This dog is out the door. > > Thanks to all who provided input. > > David Lessard > Alexandria Electronics > 50 Harrison Street > Alexandria, Ontario > (613)525-4502 > mrfixit@xxxxxxxxxxx > > ------------------------------------------ > Submit A Repair Tip For Everyone Here: > http://www.tech-assist.org/secure/tip/main.html > ------------------------------------------ > To REMOVE your email address, click here: > http://www.tech-assist.org/unsubb.html > To CHANGE your email address, click here: > http://www.techassist.net/forms/change.html > ------------------------------------------ Submit A Repair Tip For Everyone Here: http://www.tech-assist.org/secure/tip/main.html ------------------------------------------ To REMOVE your email address, click here: http://www.tech-assist.org/unsubb.html To CHANGE your email address, click here: http://www.techassist.net/forms/change.html