Philip You can only replace this Sanyo transistor w/ Sanyo part # 405-056-8701. No substitute can be used in Sanyo TV's. I hope this is the information you needed. Have a NICE DAY ! GOD Bless, Doyott Collins Collins Electronic Service 1122 South Main St. Hope, AR 71801-7237 Ph 870-777-3429 Fax 928-223-8201 E-Mail cesha@xxxxxxxxxxxxx ----- Original Message ----- From: "Philip Bader" <tjanphyl@xxxxxxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Friday, May 09, 2003 9:55 AM Subject: [TechAssist] Sanyo 31" DS31590 dead, HOT shorted. other??? > > Sanyo DS31590 (31590-02 chassis)Came in dead. > Customer said no storm at time.Tried to turn on.Must have failed in the > off mode. > Only damage I found was shorted HOT Q402 (2SD1879). I removed HOT and > in place, my 60 watt light bulb from collector of HOT to ground (emitter > ckt) for a load.Plugged in set to see standby voltages.Immediately the > brightness of my 60W bulb started cycling on/off, averaging about 46VDC > in standby. > In standby mode with the 60W bulb removed (and no HOT as well) I had a > stable +81.5VDC. > I reinstalled my bulb to HOT collector and pushed power, and set > clicked on with bright light and a stable +126.5V for about 5 seconds > and set clicks off.Push power,same 5 seconds then off again. > I then replaced the HOT with my new sub HOT D1555 (also an NTE 2331 > equiv., not exact, but I had a bunch on hand). Stand by volts on > collector, +81.5 VDC. > Powered unit up with good pix, regulation and sound. My HOT runs barley > warm. > Close inspection found all good solder in the HV areas,including H drive > transformer, tho I reflowed all anyway with solder to be sure. > I am wondering if there is any histories on this model where just the > hot goes without any other defects? > Phil Bader > -- > Philip Bader > Jan Phyl TV Inc. (estab. 1976) > 3420 Recker Hwy. Winter Haven, Fl. 33880 > Fax (863) 299-8821 > email: tjanphyl@xxxxxxxxxxxxxxx > > **************************************************************************** * > The Tech Address Book: > http://www.tech-assist.org/secure/tip/contact.html > Add a Repair Tip Here, or Change/Remove your Email Address: > http://www.tech-assist.org/secure/tip/main.html > Lost Password: > http://www.tech-assist.org and select "Lost your Login Info?". > Email Archives: > //www.freelists.org/archives/techassist/ ***************************************************************************** The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.html Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.html Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/