Don, That sure sounds like a bad comb filter. I am uploading the original service manual to the members area as "KV32S45.pdf". Bob Waterman, CET® #RI-28 Master Technician License #9109 Service Manager / Parts Manager Gemini Computer, TV, & Security Alarms (508)695-7302 (508)695-7769 FAX geminitv@xxxxxxxxxxx geminitv@xxxxxxx www.geminicomputertvsecurityalarms.com ----- Original Message ----- From: "Dan Garris" <dgarris@xxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Tuesday, April 06, 2004 12:19 AM Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > Hi Leroy and All, > > I feed an S-Video Signal to the Sony TV as you said to try below and NOW I > have a nice picture! I checked all the caps below and replace any that > seemed weak but most every cap I have seen so far was not bad just a slight > bit weak on my Capacitor Wizard ESR meter, I replaced several but none were > really bad, just slightly weak. I could not find C1266. This set uses a > Digital comb filter CXD2073S (IC3502) located on the "B" board right where > the RF input connector goes thru. I tried freeze spray all all components > and no change. > > -I can turn the PIP on, and see the picture in the PIP box but not in the > main screen. Main screen video looks just like a VCII Scrambled C-band > channel picture. > > -I can input S-Video signal using S-Video jack on back of set and I have a > nice (good) picture on the main screen! > > -I can input an A/V Signal using A/V jacks on back of set and I get same > (Scrambled) picture. > > -All Audio and OSD functions are Fine. > > -I have NO blinking LED on the front, The LED stays off after powering on > the set. > > Is this the Comb Filter IC? (part #) Any help? Thanks to all in advance!! > > Dan Garris > Garris TV > New Bern, NC > DGarris@xxxxxxxxxxx > > > > >From: "LeRoy Westlund" <llw@xxxxxxxxxx> > >Reply-To: techassist@xxxxxxxxxxxxx > >To: <techassist@xxxxxxxxxxxxx> > >Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > >Date: Mon, 5 Apr 2004 20:15:03 -0600 > > > >Dan, > >Here are three tips I found for similar problems on different (KV32S) > >models. > >Not sure if they apply to your model. > > > >1. Feed video in on the S-Video jack. If it shows a good picture, then the > >Comb filter is bad. Might be labeled CM401 on the video input board. Look > >for a black square part (1" x 1/2 " aprox.) > > > >2. Check C3501 (47 @ 25) on thhe "B" board behind the tuner. > > > >3. Check C1266 (47 @ 16), next to comb filter. > > > > If these tips do not help, then answer this question, cause there are a > >couple more tips, that I can send you. > >Question: Does the timer light flash continously ? > > > >HTH, > >LLW > > > >LeRoy Westlund > >Westlund TV & Electronics > >97 North Main "Where there's a will,... > >Centerfield, UT 84622-0087 There's always a way." > >Ph./Fax 435-528-3822 > >mailto:LLW@xxxxxxxxxx > > > >-----Original Message----- > >From: Dan Garris <dgarris@xxxxxxxxxxx> > >To: techassist@xxxxxxxxxxxxx <techassist@xxxxxxxxxxxxx> > >Date: Monday, April 05, 2004 6:38 PM > >Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > > > > > >Thanks Jim, right now I am using my SAMS PHOFACTS #4237. > > > > > >...I was hoping another technician on the list might have seen or recall > > >this type of problem on a Sony TV and could help us. I was hoping it was > >a > > >common problem. > > > > > >Dan Garris > > >Garris TV > > >New Bern, NC > > >dgarris@xxxxxxxxxxx > > > > > > > > > > > >>From: "becyn" <becyn@xxxxxxxxxx> > > >>Reply-To: techassist@xxxxxxxxxxxxx > > >>To: <techassist@xxxxxxxxxxxxx> > > >>Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > >>Date: Mon, 5 Apr 2004 20:05:06 -0400 > > >> > > >>Dan, > > >> > > >>I can't locate a manual for this one. maybe someone on the list has one > >... > > >>PIP is a good candidate, but sometimes there are video switching IC's on > > >>the > > >>main pcb that can fail. At this point your gonna have to "go in". Sorry > >i > > >>couldn't be of more assistance... > > >> > > >>Jim McVey > > >>McVey Alltronix > > >>327 Broadway > > >>Newburgh Ny 12550 > > >>ph: 845 561 8383 > > >>fx: 845 561 9017 > > >>Consumer electronics & > > >>computer service. > > >>Factory authorized for > > >>over twenty brands. > > >>----- Original Message ----- > > >>From: "Dan Garris" <dgarris@xxxxxxxxxxx> > > >>To: <techassist@xxxxxxxxxxxxx> > > >>Sent: Monday, April 05, 2004 7:04 PM > > >>Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > >> > > >> > > >> > I was thinking the same thing Jim. I checked all caps - no fish smell > > >>caps - > > >> > in fact the pc board almost looks new. > > >> > > > >> > If it is in the PIP board - How could I bypass the PIP circuit on > >this > > >> > model/chassis? > > >> > > > >> > Dan Garris > > >> > Garris TV > > >> > New Bern, NC > > >> > dgarris@xxxxxxxxxxx > > >> > > > >> > >From: "becyn" <becyn@xxxxxxxxxx> > > >> > >Reply-To: techassist@xxxxxxxxxxxxx > > >> > >To: <techassist@xxxxxxxxxxxxx> > > >> > >Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > >> > >Date: Mon, 5 Apr 2004 18:45:34 -0400 > > >> > > > > >> > >Still sounds like the PIP board. Probably some bad "fish" caps > >and/or > > >> > >associated corrosion. > > >> > > > > >> > >Jim McVey > > >> > >McVey Alltronix > > >> > >327 Broadway > > >> > >Newburgh Ny 12550 > > >> > >ph: 845 561 8383 > > >> > >fx: 845 561 9017 > > >> > >Consumer electronics & > > >> > >computer service. > > >> > >Factory authorized for > > >> > >over twenty brands. > > >> > >----- Original Message ----- > > >> > >From: "Dan Garris" <dgarris@xxxxxxxxxxx> > > >> > >To: <techassist@xxxxxxxxxxxxx> > > >> > >Sent: Monday, April 05, 2004 5:34 PM > > >> > >Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > >> > > > > >> > > > > >> > > > I read that tip and all others.... however my picture is not > >black, > > >>I > > >> > >can > > >> > > > see color in the slightly negative *video that I do have, also > >the > > >>video > > >> > >has > > >> > > > what appears to be no horiz/vert sync - NOW the PIP works and has > >a > > >>nice > > >> > > > picture, OSD works, all the Audio works. I can watch TV thru the > > >>small > > >> > >PIP > > >> > > > window just fine but the not on the main picture. > > >> > > > > > >> > > > *(main picture looks just like the VCII Scrambled video on a > >C-band > > >>dish > > >> > > > picture) (pretty good description of what it looks like). > > >> > > > > > >> > > > Dan Garris > > >> > > > Garris TV > > >> > > > New Bern, NC > > >> > > > dgarris@xxxxxxxxxxx > > >> > > > > > >> > > > > > >> > > > >From: "Intrepid Video Support" <support@xxxxxxxxxxxxxxxxxx> > > >> > > > >Reply-To: techassist@xxxxxxxxxxxxx > > >> > > > >To: <techassist@xxxxxxxxxxxxx> > > >> > > > >Subject: [TechAssist] Re: Help! - Sony KV32S45 TV > > >> > > > >Date: Mon, 5 Apr 2004 15:56:39 -0400 > > >> > > > > > > >> > > > >Dan, > > >> > > > >Sounds like it... > > >> > > > >SONY \KV32S45\Black no picture no video no color* IC351 had > >video > > >>in > > >> > >but > > >> > > > >garbage out the led would blink 1 > > >> > > > >ea sec\\\\IC351 (CXA2095S)\\\\\\\\ > > >> > > > > > > >> > > > > > > >> > > > > > > >> > > > >Jeff Dougherty > > >> > > > >Intrepid Video TV/VCR > > >> > > > >263 S Front St > > >> > > > >Steelton PA 17113 > > >> > > > >fax...717-564-4952 > > >> > > > >www.intrepid-video.com www.tech-repair.net > > >> > > > > > > >> > > > >----- Original Message ----- > > >> > > > >From: "Dan Garris" <dgarris@xxxxxxxxxxx> > > >> > > > >To: <techassist@xxxxxxxxxxxxx> > > >> > > > >Sent: Monday, April 05, 2004 3:42 PM > > >> > > > >Subject: [TechAssist] Help! - Sony KV32S45 TV > > >> > > > > > > >> > > > > > > >> > > > >Make : Sony > > >> > > > >Model : KV32S45 > > >> > > > >Chassis: SCC-S07B-A (MFD Oct 1998) > > >> > > > >Tuner: # 8-598-431-00 > > >> > > > > > > >> > > > >Had all snow on all channels, Audio and OSD worked fine, LED was > > >>not > > >> > > > >blinking. I replaced Tuner (8-598-431-00) still no change. I > > >>checked > > >> > >all > > >> > > > >tuner voltages, all ok but NO 5 volt VCC on pin 3, replaced > >leaky > > >>D1103 > > >> > > > >5.6v > > >> > > > >Zener diode and this restored 5volt VCC to tuner. > > >> > > > > > > >> > > > >Now tuner appears to be working, but picture is scrambled, with > >a > > >> > >negative > > >> > > > >look and no vert/horiz sync. Audio & OSD work fine! The PIP > >picture > > >>in > > >> > >the > > >> > > > >small PIP box looks great! But the main picture is scrambled > > >>looking > > >>as > > >> > > > >described above. I checked all caps near tuner and on the "P" > >(PIP) > > >>and > > >> > >"B" > > >> > > > >boards. WHen I plug in a VCR into the rear A/V jacks, the > >picture > > >>is > > >> > >still > > >> > > > >scrambled looking with a bit of a negative look and no > >vert/horiz > > >>sync. > > >> > > > > > > >> > > > >Now is another case of a bad Jungle IC351 CXA2095S failure? > >Help? > > >> > > > > > > >> > > > >Dan Garris > > >> > > > >Garris TV > > >> > > > >New Bern, NC > > >> > > > >dgarris@xxxxxxxxxxx > > >> > > > > > > >> > > > > > >_________________________________________________________________ > > >> > > > >MSN Toolbar provides one-click access to Hotmail from any Web > >page > > >>- > > >> > >FREE > > >> > > > >download! http://toolbar.msn.com/go/onm00200413ave/direct/01/ > > >> > > > > > > >> > > > > > > >> > > > > > >> > > > > >> > > >--------------------------------------------------------------------------- > > >> > >-- > > >> > > > >Lost Password: > > >> > > > >http://www.tech-assist.org and select "Login Problems?". > > >> > > > >Email Archives: > > >> > > > >//www.freelists.org/archives/techassist/ > > >> > > > > > > >> > > > > > > >> > > > > > > >> > > > > > > >> > > > > > >> > > > > >> > > >--------------------------------------------------------------------------- > > >> > >-- > > >> > > > >Lost Password: > > >> > > > >http://www.tech-assist.org and select "Login Problems?". > > >> > > > >Email Archives: > > >> > > > >//www.freelists.org/archives/techassist/ > > >> > > > > > >> > > > _________________________________________________________________ > > >> > > > MSN Toolbar provides one-click access to Hotmail from any Web > >page - > > >> > >FREE > > >> > > > download! http://toolbar.msn.com/go/onm00200413ave/direct/01/ > > >> > > > > > >> > > > > > >> > > > > > >> > > > >> > > >-------------------------------------------------------------------------- > > >> > >--- > > >> > > > Lost Password: > > >> > > > http://www.tech-assist.org and select "Login Problems?". > > >> > > > Email Archives: > > >> > > > //www.freelists.org/archives/techassist/ > > >> > > > > > >> > > > > >> > > > > >> > > > > >> > > > >> > > >--------------------------------------------------------------------------- > > >>-- > > >> > >Lost Password: > > >> > >http://www.tech-assist.org and select "Login Problems?". > > >> > >Email Archives: > > >> > >//www.freelists.org/archives/techassist/ > > >> > > > >> > _________________________________________________________________ > > >> > Check out MSN PC Safety & Security to help ensure your PC is > >protected > > >>and > > >> > safe. http://specials.msn.com/msn/security.asp > > >> > > > >> > > > >> > > > >>-------------------------------------------------------------------------- > > >>--- > > >> > Lost Password: > > >> > http://www.tech-assist.org and select "Login Problems?". > > >> > Email Archives: > > >> > //www.freelists.org/archives/techassist/ > > >> > > > >> > > >> > > >> > > >>-------------------------------------------------------------------------- > >--- > > >>Lost Password: > > >>http://www.tech-assist.org and select "Login Problems?". > > >>Email Archives: > > >>//www.freelists.org/archives/techassist/ > > > > > >_________________________________________________________________ > > >Get rid of annoying pop-up ads with the new MSN Toolbar - FREE! > > >http://toolbar.msn.com/go/onm00200414ave/direct/01/ > > > > > > > > >--------------------------------------------------------------------------- > >-- > > >Lost Password: > > >http://www.tech-assist.org and select "Login Problems?". > > >Email Archives: > > >//www.freelists.org/archives/techassist/ > > > > > > > > >--------------------------------------------------------------------------- -- > >Lost Password: > >http://www.tech-assist.org and select "Login Problems?". > >Email Archives: > >//www.freelists.org/archives/techassist/ > > _________________________________________________________________ > Watch LIVE baseball games on your computer with MLB.TV, included with MSN > Premium! > http://join.msn.com/?page=features/mlb&pgmarket=en-us/go/onm00200439ave/direct/01/ > > > -------------------------------------------------------------------------- --- > Lost Password: > http://www.tech-assist.org and select "Login Problems?". > Email Archives: > //www.freelists.org/archives/techassist/ ----------------------------------------------------------------------------- Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/