What is the Sony p/n for the "G" board for this model? (I'd be interesting to see what Tritronics cost on the part is) Also, When set comes back in, I will install the 2SC4834"P"s so they willl run cooler and also the VDR in P/S and all the electrolytics near the Horiz drive transformer. Since I am at home and not at the shop, I only recall (1) VDR in the P/S. Are there (2) VDR's in this model? I do recall in other models as many as (3) but only recall (1) in this model. I'll research more when I get to the shop. Garris Radio & TV Danny Garris New Bern, NC dgarris@xxxxxxxxxxx Ph: (252) 638-4477 >From: "Shoreline Electronics" <jstielau@xxxxxxxx> >Reply-To: techassist@xxxxxxxxxxxxx >To: <techassist@xxxxxxxxxxxxx> >Subject: [TechAssist] Re: Sony KV-32S20 [repeat failure] >Date: Wed, 18 Aug 2004 22:44:14 -0400 > >See if Tritronics list the G baord......for $40 bucks it will save your >sanity! > >========================== >Jeff Stielau >Shoreline Electronics Repair >344 East Main Street >Clinton,CT 06413 >860-399-1861 >860-664-3535 (fax) >jstielau@xxxxxxxx >======================== >"If you push something hard enough it will fall over." >Fudd's First Law of Opposition - Sir Sidney Fudd > > >----- Original Message ----- >From: "Dan Garris" <dgarris@xxxxxxxxxxx> >To: <techassist@xxxxxxxxxxxxx> >Sent: Wednesday, August 18, 2004 6:05 PM >Subject: [TechAssist] Re: Sony KV-32S20 [repeat failure] > > > > I did resolder the Horiz driver transformer, but I did not replace the >VDR > > nor the Caps in the power supply. That was exactly my next move but I >wanted > > to get some outside suggestions so when the set comes back in next week >I'll > > know exactly what other components to replace to prevent a repeat >failure. > > > > Garris Radio & TV > > Danny Garris > > New Bern, NC > > dgarris@xxxxxxxxxxx > > Ph: (252) 638-4477 > > > > > > >From: peggs <peggs@xxxxxxxxxxxxx> > > >Reply-To: techassist@xxxxxxxxxxxxx > > >To: techassist@xxxxxxxxxxxxx, techassist@xxxxxxxxxxxxx > > >Subject: [TechAssist] Re: Sony KV-32S20 [repeat failure] > > >Date: Wed, 18 Aug 2004 15:53:41 -0700 > > > > > >resolder H drive tranformer > > >replace VDR's in Ps > > >replace electrolytic near H drive transformer(.47uF) > > > > > >Peggs > > > > > >At 01:23 PM 8/18/04, Danny Garris wrote: > > > >I repaired a dead Sony 32" KV-32S20 TV w/ Shorted Q601, Q602 >(2SC4834) > > >and > > > >Open R607 .1ohm 1/2 W and Shorted HOT 2SC5148 (8-729-035-75). > > > > > > > >Set played fine after repair for 2 days in shop. Customer picked-up >set > > >and > > > >a couple days later called to say set was dead again! I found Q601, >Q602 > > > >shorted and R607 Open this time. (The HOT was ok) Again Set played >fine > > >for > > > >two days in-shop after second repair. > > > > > > > >Customer called again a few days later and said set is dead again. >What > > >am I > > > >missing? > > > > > > > >Garris Radio & TV > > > >Danny Garris > > > >New Bern, NC > > > >dgarris@xxxxxxxxxxx > > > >Ph: (252) 638-4477 > > > > > > > > > > > > > > > > >--------------------------------------------------------------------------- >-- > > > >Lost Password: > > > >http://www.tech-assist.org and select "Login Problems?". > > > >Email Archives: > > > >//www.freelists.org/archives/techassist/ > > > > > > > > > >--------------------------------------------------------------------------- >-- > > >Lost Password: > > >http://www.tech-assist.org and select "Login Problems?". > > >Email Archives: > > >//www.freelists.org/archives/techassist/ > > > > > > > > >-------------------------------------------------------------------------- >--- > > Lost Password: > > http://www.tech-assist.org and select "Login Problems?". > > Email Archives: > > //www.freelists.org/archives/techassist/ > > > > >----------------------------------------------------------------------------- >Lost Password: >http://www.tech-assist.org and select "Login Problems?". >Email Archives: >//www.freelists.org/archives/techassist/ ----------------------------------------------------------------------------- Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/