Good idea to check those..Dan. Don't make it your next move...make it your second. Mark it in your database. I did....after finding out exactly what you just learned. -Ed- Ed Gaidies Tel-Tek Electronics Ontario-Canada teltek3@xxxxxxxxxxxx On 18-Aug-04, at 6:05 PM, Dan Garris wrote: > I did resolder the Horiz driver transformer, but I did not replace the > VDR > nor the Caps in the power supply. That was exactly my next move but I > wanted > to get some outside suggestions so when the set comes back in next > week I'll > know exactly what other components to replace to prevent a repeat > failure. > > Garris Radio & TV > Danny Garris > New Bern, NC > dgarris@xxxxxxxxxxx > Ph: (252) 638-4477 > > >> From: peggs <peggs@xxxxxxxxxxxxx> >> Reply-To: techassist@xxxxxxxxxxxxx >> To: techassist@xxxxxxxxxxxxx, techassist@xxxxxxxxxxxxx >> Subject: [TechAssist] Re: Sony KV-32S20 [repeat failure] >> Date: Wed, 18 Aug 2004 15:53:41 -0700 >> >> resolder H drive tranformer >> replace VDR's in Ps >> replace electrolytic near H drive transformer(.47uF) >> >> Peggs >> >> At 01:23 PM 8/18/04, Danny Garris wrote: >>> I repaired a dead Sony 32" KV-32S20 TV w/ Shorted Q601, Q602 >>> (2SC4834) >> and >>> Open R607 .1ohm 1/2 W and Shorted HOT 2SC5148 (8-729-035-75). >>> >>> Set played fine after repair for 2 days in shop. Customer picked-up >>> set >> and >>> a couple days later called to say set was dead again! I found Q601, >>> Q602 >>> shorted and R607 Open this time. (The HOT was ok) Again Set played >>> fine >> for >>> two days in-shop after second repair. >>> >>> Customer called again a few days later and said set is dead again. >>> What >> am I >>> missing? >>> >>> Garris Radio & TV >>> Danny Garris >>> New Bern, NC >>> dgarris@xxxxxxxxxxx >>> Ph: (252) 638-4477 >>> >>> >>> >>> --------------------------------------------------------------------- >>> -------- >>> Lost Password: >>> http://www.tech-assist.org and select "Login Problems?". >>> Email Archives: >>> //www.freelists.org/archives/techassist/ >> >> >> ---------------------------------------------------------------------- >> ------- >> Lost Password: >> http://www.tech-assist.org and select "Login Problems?". >> Email Archives: >> //www.freelists.org/archives/techassist/ > > > > ----------------------------------------------------------------------- > ------ > Lost Password: > http://www.tech-assist.org and select "Login Problems?". > Email Archives: > //www.freelists.org/archives/techassist/ > ----------------------------------------------------------------------------- Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/