[TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open ( DAV-S500)-UPDATE &FIX
- From: "Phillip R. Hull" <phil245@xxxxxxxxxxxxx>
- To: <techassist@xxxxxxxxxxxxx>
- Date: Sun, 25 Jan 2004 12:42:02 -0500
I replace them and the replacment is the size of a fly speck. Its real
tricky to solder in.
Phillip R. Hull STET
phil245@xxxxxxxxxxxxx
FAX 517-569-2242
----- Original Message -----
From: "George" <grndmstrg@xxxxxxxxxxxx>
To: <techassist@xxxxxxxxxxxxx>
Sent: Sunday, January 25, 2004 3:51 AM
Subject: [TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open (
DAV-S500)-UPDATE &FIX
> Don,
> Bridging a damaged off value resistor to bring it to the correct value
works
> for temporary testing but it is still bad and will probably continue going
> up in value, granted maybe not as fast but that is not proper repair that
> will go bad again. Always best to replace it. Hey I am not saying bridging
> is bad if you need a value that is not available but use new good
resistors
> for all. Just my two bits worth.
>
> George
> Afana Electronics
> Moreno Valley, CA
>
> ----- Original Message -----
> From: <hartstv@xxxxxxxxxxx>
> To: <techassist@xxxxxxxxxxxxx>
> Sent: Saturday, January 24, 2004 12:41 PM
> Subject: [TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open (
> DAV-S500)-UPDATE &FIX
>
>
> > Update & FIX,Tks to Ty Kraemer for uploading the service data to the
> members
> > section.After reading all the updates& mods the repair was fairly
> > simple.Q002 & R011 need to be replaced & a wire harness.I made my own
> > harness & found it easier to parrallel a 1K ohm resistor to R011 rather
> than
> > replace it with a 470 ohm smd.Replaced Q002 with a 2SB511.Cleaned &
tested
> > and is good to go................
> > Don of HARTS-TVCR-ASC
> > 9 Robert St,Oromocto,NB,Canada,E2V3N2
> > Tel-506-357-9785,Fax-506-357-6010
> > hartstv@xxxxxxxxxxx
> >
> >
> >
> > ----- Original Message -----
> > From: "al m" <ampm@xxxxxxx>
> > To: <techassist@xxxxxxxxxxxxx>
> > Sent: Friday, January 23, 2004 9:46 PM
> > Subject: [TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open (
> > DAV-S500)
> >
> >
> > > Just had a Sony DVD 5 disc player that the tray wouldn't open. The
> problem
> > > was the laser assembly pivot holder was broken, and the switch for up
> and
> > > down wasn't making contact correctly. Only way to fix was to either
get
> > the
> > > whole housing or repair the broken housing. I rigged the housing. I
> don't
> > > know if this is the same housing or not but it's a idea.
> > > Al Marquardt
> > > ampm@xxxxxxx
> > > Al Marquardt Electronic Repair
> > > 206 W Main
> > > Girardville Pa. 17935
> > > ----- Original Message -----
> > > From: <hartstv@xxxxxxxxxxx>
> > > To: <techassist@xxxxxxxxxxxxx>
> > > Sent: Friday, January 23, 2004 2:45 PM
> > > Subject: [TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open (
> > > DAV-S500)
> > >
> > >
> > > > Jim,I know this is replying to an older post but I just received one
> of
> > > > these units in for repair with the same problems.When I checked my
> parts
> > > > supplyer here in Canada using the X-4954-896-1 part # for Q002,I get
> the
> > > > following reply;
> > > > Housing -Q200 ASSY,cost=63.78
> > > > Is this correct?Q002 is a SMD device,not sure if a regulator or
what,
> > BUT
> > > 64
> > > > bucks sounds a little pricey.What exactly is Q002?Would like to try
a
> > sub
> > > > for test purposes & check to see if this unit has additional
problems
> as
> > > you
> > > > mention in your post....TIA....
> > > > Don of HARTS-TVCR-ASC
> > > > 9 Robert St,Oromocto,NB,Canada,E2V3N2
> > > > Tel-506-357-9785,Fax-506-357-6010
> > > > hartstv@xxxxxxxxxxx
> > > >
> > > >
> > > >
> > > > ----- Original Message -----
> > > > From: "Jim Myers" <jr.myers@xxxxxxxxxxx>
> > > > To: <techassist@xxxxxxxxxxxxx>
> > > > Sent: Monday, June 09, 2003 11:25 AM
> > > > Subject: [TechAssist] Re: Sony AV/DVD M# HCD-S500 Tray will not open
(
> > > > DAV-S500)
> > > >
> > > >
> > > > > There is a part change for Q002 failure, P/N X-4954-896-1 will get
> you
> > > the
> > > > > new transistor and a wired socket, also change R011 from 1K to 470
> > ohms.
> > > > > We've done a couple of these and this may fix your problem but
> > > additional
> > > > > problems may exist, like no disk errors.
> > > > > **************************************************
> > > > > Jim Myers
> > > > > Since 1972
> > > > > Telrad Electronic Services Co.
> > > > > Fort Wayne, IN 46815
> > > > > *************************************************
> > > > > ----- Original Message -----
> > > > > From: "Phillip R. Hull" <phil245@xxxxxxxxxxxxx>
> > > > > To: <techassist@xxxxxxxxxxxxx>
> > > > > Sent: Monday, June 09, 2003 10:08 AM
> > > > > Subject: [TechAssist] Sony AV/DVD M# HCD-S500 Tray will not open (
> > > > DAV-S500)
> > > > >
> > > > >
> > > > > Techs,
> > > > > I usually do not repair these Sony DVD's but a rental store
brought
> in
> > > two
> > > > > of these(same symptom) and I said I would look at them.
> > > > > Unit turns on and has diplay lit but will not eject the CD. When
> you
> > > > press
> > > > > open/close button you here a relay click but tray will not open
and
> CD
> > > > does
> > > > > not spin. It has 12v, 6.5v and 3.3 volt on the plug from power
> > supply.
> > > > Ic
> > > > > 903 in power supply gets real hot (I think its 903 but the last
> number
> > > is
> > > > > distorted ) and so does IC 607 on DVD board. any help on this
would
> > be
> > > > > appreciated, before I order a manual.
> > > > >
> > > > > P.S. I Just noticed that the display does not lite up until you
> > press
> > > > the
> > > > > open close button
> > > > >
> > > > > Thanks
> > > > > Phillip R Hull STET
> > > > > phil245@xxxxxxxxxxxxx
> > > > > FAX 517--569-3075
> > > > >
> > > > >
> > > >
> > >
> >
>
****************************************************************************
> > > > > *
> > > > > The Tech Address Book:
> > > > > http://www.tech-assist.org/secure/tip/contact.html
> > > > > Add a Repair Tip Here, or Change/Remove your Email Address:
> > > > > http://www.tech-assist.org/secure/tip/main.htm
> > > > > Lost Password:
> > > > > http://www.tech-assist.org and select "Lost your Login Info?".
> > > > > Email Archives:
> > > > > //www.freelists.org/archives/techassist/
> > > > >
> > > > >
> > > >
> > >
> >
>
****************************************************************************
> > > > *
> > > > > The Tech Address Book:
> > > > > http://www.tech-assist.org/secure/tip/contact.html
> > > > > Add a Repair Tip Here, or Change/Remove your Email Address:
> > > > > http://www.tech-assist.org/secure/tip/main.htm
> > > > > Lost Password:
> > > > > http://www.tech-assist.org and select "Lost your Login Info?".
> > > > > Email Archives:
> > > > > //www.freelists.org/archives/techassist/
> > > > >
> > > >
> > > >
> > >
> >
>
> --------------------------------------------------------------------------
> > > ---
> > > > Jokes, complaints, off topics, general chat. Everything other than
> > repair
> > > > help problems can be found at this new list. No archives and posts
> will
> > > not
> > > > be found on Google or any other engine!To remove or join, click:
> > > > mailto:ecartis@xxxxxxxxxxxxxxx?subject=subscribe%20chat
> > > > Send to the list at chat@xxxxxxxxxxxxxxx once subscribed.
> > >
> >
>
> --------------------------------------------------------------------------
> > > ---
> > > > Lost Password:
> > > > http://www.tech-assist.org and select "Login Problems?".
> > > > Email Archives:
> > > > //www.freelists.org/archives/techassist/
> > > >
> > > >
> > >
> > >
> >
>
> --------------------------------------------------------------------------
> > ---
> > > Jokes, complaints, off topics, general chat. Everything other than
> repair
> > > help problems can be found at this new list. No archives and posts
will
> > not
> > > be found on Google or any other engine!To remove or join, click:
> > > mailto:ecartis@xxxxxxxxxxxxxxx?subject=subscribe%20chat
> > > Send to the list at chat@xxxxxxxxxxxxxxx once subscribed.
> >
>
> --------------------------------------------------------------------------
> > ---
> > > Lost Password:
> > > http://www.tech-assist.org and select "Login Problems?".
> > > Email Archives:
> > > //www.freelists.org/archives/techassist/
> > >
> >
> >
>
> --------------------------------------------------------------------------
> ---
> > Jokes, complaints, off topics, general chat. Everything other than
repair
> > help problems can be found at this new list. No archives and posts will
> not
> > be found on Google or any other engine!To remove or join, click:
> > mailto:ecartis@xxxxxxxxxxxxxxx?subject=subscribe%20chat
> > Send to the list at chat@xxxxxxxxxxxxxxx once subscribed.
>
> --------------------------------------------------------------------------
> ---
> > Lost Password:
> > http://www.tech-assist.org and select "Login Problems?".
> > Email Archives:
> > //www.freelists.org/archives/techassist/
> >
>
>
> --------------------------------------------------------------------------
---
> Jokes, complaints, off topics, general chat. Everything other than repair
> help problems can be found at this new list. No archives and posts will
not
> be found on Google or any other engine!To remove or join, click:
> mailto:ecartis@xxxxxxxxxxxxxxx?subject=subscribe%20chat
> Send to the list at chat@xxxxxxxxxxxxxxx once subscribed.
> --------------------------------------------------------------------------
---
> Lost Password:
> http://www.tech-assist.org and select "Login Problems?".
> Email Archives:
> //www.freelists.org/archives/techassist/
>
>
-----------------------------------------------------------------------------
Jokes, complaints, off topics, general chat. Everything other than repair
help problems can be found at this new list. No archives and posts will not
be found on Google or any other engine!To remove or join, click:
mailto:ecartis@xxxxxxxxxxxxxxx?subject=subscribe%20chat
Send to the list at chat@xxxxxxxxxxxxxxx once subscribed.
-----------------------------------------------------------------------------
Lost Password:
http://www.tech-assist.org and select "Login Problems?".
Email Archives:
//www.freelists.org/archives/techassist/
Other related posts:
