STORM DAMAGE!!! Robert tvservice@xxxxxxxxxxxxxxxxxxx H & H Electronics Inc ----- Original Message ----- From: "Phil Bader" <philbad@xxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Tuesday, November 05, 2002 2:51 PM Subject: [TechAssist] fix: Sony KV27V40 clicks only,found burnt traces] > > Final tally: > V reg IC601 shorted MXO541,872903965 > Vert output IC541 TDA8172 (bad?) > Resistor R606 (.47 ohm 1W) in IC601 ckt.was open > Zener diode D205 shorted: 30Volt, MTZJ-30D, 871958222 in 30v tuner line > to tuner pin#2. > Tuner (bad?) 859843100, "REP" ver from TroTronics > Jungle CXA2061S,875208309 > Repair an open trace from (-) of cap C212 to jumper JW240 near audio > IC401. > Checked video inputs and tuning all OK now. > Phil Bader > > Phil Bader wrote: > > > > that finished the job! > > Phil Bader > > > > Gemini Computer & TV wrote: > > > > > > That diode is a MTZJ-30D, Sony part# 8-719-982-22. I cannot cross it but I > > > do believe that it is a 30 volt zener. > > > > > > Bob Waterman, CET® #RI-28 > > > Master Technician License #9109 > > > Service Manager > > > Gemini Computer, TV, & Security Alarms > > > (508)695-7302 > > > (508)695-7769 FAX > > > geminitv@xxxxxxxxxxxxxxxx > > > geminitv@xxxxxxx > > > > > > ----- Original Message ----- > > > From: "Phil Bader" <philbad@xxxxxxxxxx> > > > To: <techassist@xxxxxxxxxxxxx> > > > Sent: Tuesday, November 05, 2002 1:19 PM > > > Subject: [TechAssist] Sony KV27V40 clicks only,found burnt traces] > > > > > > > > > > > After replacing main V reg IC601(MX0541, and resistor nearby R606(.47 > > > > ohm 1w) unit powered up. Tunung looks like tuner bad. One partially > > > > tuned station. I ordered a tuner 8-598-431-00 rebuilt, but before I > > > > installed it I noticed a zener diode D205 ("D30") connected to tuner > > > > pin# 2 shorted. > > > > Is D205 a 30volt zener??? NEED this value! > > > > Phil Bader > > > > > > > > Larry, thanks for the fax. > > > > There does not seem to be any IC1509,Q1505...No 1500 series anything in > > > > this specific chassis.I did change IC541 the TDA8172 vert output IC, > > > > same symptom.My next suspect is the CXA2061s Y/C jungle since I think > > > > this also provides deflection pulses. > > > > Phil Bader > > > > > > > > "Larry E." wrote: > > > > > > > > > > Phil, four blinks is No vertical deflection (V STOP). Mutes video > > > > > signal, Sony says to check IC1509, Q1505. Hope this helps, Larry > > > > > Larry Eastman > > > > > American TV & Electronics > > > > > Crystal River, Fl. 34428 > > > > > > > > > > Phil Bader wrote: > > > > > > > > > > > Found traces between the rear jacks burnt open,and another from (-) of > > > > > > C212 to jumper JW240 near audio IC401.Repaired both...Plug in, relay > > > > > > will click,may click every 10 seconds for a while,never any > > > > > > HV,sound,etc.Finally the front stereo LED is on constant, the "stand > > > by" > > > > > > LED below blinks a series of four times, waits, then four times... > > > > > > Anyone know this error code? > > > > > > Phil Bader > > > > > > > > > > > > > > > > -- > > > > > Larry Eastman > > > > > American TV & Electronics > > > > > Crystal River, Fl. > > > > > http://www.tvjunkyard.com > > > > > > > > > -- > > ------------------------------------------ > To REMOVE your email address, click here: > http://www.tech-assist.org/unsubb.html > To CHANGE your email address, click here: > http://www.techassist.net/forms/change.html > ------------------------------------------ > ***NEW*** Tips Added Instantly!!!*** > Submit Repair Tips here: > http://www.tech-assist.org/secure/tip/ > ------------------------------------------ To REMOVE your email address, click here: http://www.tech-assist.org/unsubb.html To CHANGE your email address, click here: http://www.techassist.net/forms/change.html ------------------------------------------ ***NEW*** Tips Added Instantly!!!*** Submit Repair Tips here: http://www.tech-assist.org/secure/tip/