Hello, I replaced R812 and R828, repaired the burned spots and also replaced C826 (25 volt 2200 uf) which was poofed out on the top and bad. Set played for about 2 hours and smoked C826 again and R828 is open again. Does anyone know where to get the schematic for this tv or maybe what I am missing in this circut that is causing the cap to smoke. Shaun Advanced Electronics 224 West Riverview Ave. Fort Morgan, CO 80701 satguy@xxxxxxxxxxxxx ----- Original Message ----- From: <tvservice@xxxxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Monday, October 06, 2003 3:35 PM Subject: [TechAssist] Re: Curtis Mathis CM27101S burt resistors > Schematic is difficult to read very small print R812 (not listed in parts > list) > appears to be 300 or 500 ohm 1 watt across Q805 C-E > R828 is 560 ohm 1/4 watt at base of Q805 > D822 at base of Q805 is 5.6volt zener > hth > Robert > tvservice@xxxxxxxxxxxxx > H & H Electronics Inc > Dallas, TX > ----- Original Message ----- > From: "Advanced Electronics" <satguy@xxxxxxxxxxxxx> > To: "tec" <techassist@xxxxxxxxxxxxx> > Sent: Monday, October 06, 2003 12:25 PM > Subject: [TechAssist] Re: Curtis Mathis CM27101S burt resistors > > > > The chassis looks like a Daewoo but might not be. I am familiar with the > > common problems with Daewoo tv's and this one is different. The resistors > > that are burned are R812 and R828.They both go to a transistor Q805 > > (2SC3205). > > Shaun > > > > Advanced Electronics > > 224 West Riverview Ave. > > Fort Morgan, CO 80701 > > > > satguy@xxxxxxxxxxxxx > > ----- Original Message ----- > > From: "Satguy" <satguy@xxxxxxxxxxxxx> > > To: <satguy@xxxxxxxxxxxxx> > > Sent: Monday, October 06, 2003 11:12 AM > > Subject: Fw: [TechAssist] Re: Curtis Mathis CM27101S burt resistors > > > > > > > > > > Shaun > > > Advanced Electronics > > > Fort Morgan, CO 80701 > > > > > > satguy@xxxxxxxxxxxxx > > > ----- Original Message ----- > > > From: "Gemini Computer & TV" <geminitv@xxxxxxxxxxxxxxxx> > > > To: <techassist@xxxxxxxxxxxxx> > > > Sent: Monday, October 06, 2003 7:09 AM > > > Subject: [TechAssist] Re: Curtis Mathis CM27101S burt resistors > > > > > > > > > > See if any of these might help: > > > > --------------------------------------------------------------- > > > > Text pasted from WinSTIPS 2.0 > > > > http://www.ServiceSoftware.com > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead > > > > > > > > > > > > > > > > The Service Bulletin Notes For The Regulator Circuit Said To Check The > > > > Following Out Of Circuit: R818 (.33 Ohm 1w), R806 (390k 1/2w), R812 > (100 > > > Ohm > > > > 1/4w). > > > > > > > > Failure On These Are Highly Possible Due To Thermal Runaway. Then > Test > > > > Q805, Q803 And Q804. To Test You Might Remove Q402 (Hot), And Use A > > > > 25w-120v Bulb Across The 103vdc And See If It Flashes. > > > > > > > > Replace C404 1mf-160v With A 3.3mf-160v No Matter What, And Place A 33 > > Ohm > > > > 1/4w On Q402 Between Base To Emitter. In My Fix I Had To Replace > Q402, > > > And > > > > Then Added The Resistor. > > > > > > > > The Notes I Have For Crossing These Are: > > > > Q402 - D1880 - Nte 2353 (Hot) > > > > Q803 - C2500 - Nte 2363 > > > > Q804 - E13009-2 - Nte 379 > > > > Q805 - C3203 - Nte 382 > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead - H.o.t. shorted & Fuse blown > > > > > > > > Herman Ackerman > > > > > > > > Q804E13009-2 (Kse13009y) I used 2sc4834, Q805 Ktc3203 used 2sc3203 > > h.o.t. > > > > 2sd1880 used 2sd1879 ok. > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead - H.o.t. shorted & Fuse blown > > > > > > > > Jesse Morris > > > > > > > > Q402, Q804, Q805, C403, C418, and F801 > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead No Power Up > > > > > > > > Computer & Comm Solutions Www.Ccsinc.Com 804-642-9731 > > > > > > > > Q803 C2500 R/W Sk9453, Q804 E13009 R/W Sk10000, Q402 2sd1880 R/W > > 2sd1879, > > > > Q805 C3203 R/W C3203 C404 1uf@160v Had Bad Esr > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead No Power Up (All Smps Components Check Good !) > > > > > > > > Bay Electronics Inc. > > > > > > > > Remove R807 (47 Ohm) Scrape Leads Reinstall Or Replace R807 The Unit I > > > Fixed > > > > Had An Invisible Bad Joint There Due To Overheating.. What A Dog ! > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead. > > > > > > > > Ford's Tv & Video Service > > > > > > > > Open Capactor, C404 (1 Uf 160v), Shorted Transistor, Q803(2sc3203), > > > > Defective Transitors, Q805 (2sc2500), Q804 (E13009-2), Q402 (2sd1880), > > > Open > > > > Resistor, R815 (0.33 Ohm 1 W). > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Dead. > > > > > > > > Ford'S Tv & Video Service > > > > > > > > Open Cap, C404 (1uf 160v), Shorted Transistor, Q803(Ksc2500), > Defective > > > > Transistors, Q805(Ktc3203), Q804(Kse13009), Q402 (2sd1880), Open > > Resistor, > > > > R818 (0.33 Ohm 1 W) > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > H.o.t. overheating > > > > > > > > Daewoo Fsb 99ctv2 > > > > > > > > add a 33 ohm resistor from b-e of h.o.t. > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > H.O.T. Overheating > > > > > > > > > > > > > > > > Here Is The List Of Things That Daewoo Told Me To Replace Or Test When > > > There > > > > Is Thermal Runaway In Horz Out. They Say That This Is Good For > Shutdown > > > > After It Has Been On For Awhile. > > > > > > > > Original Replace > > > > Q402- 2sd1880 2sd2539> > > > > Q803- Ksc2509b 2sc2355 Or Nte2363 > > > > Q804- Kse!#13009 2sc3890 Or Nte379 > > > > Q805- Ktc3203 2sc2235 Or Nte2382 > > > > Replace : C808, C404 , C410 , C414 , C413 > > > > Check : C412 , C401 Replace If Necessary. > > > > Change C505 To 1000pf@100v , R420 To 1.8k 1 Watt > > > > Check Or Replace R516 10k Pot (Which Will Cause Pic To Narrow On > > Right) > > > > > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Pix Shifted, leaving black bar on Left side > > > > > > > > Daewoo Svc Bulletin #99ctv1 > > > > > > > > Trimpot R516 (10k) open and D504 open due to excessive current flow. > > R420 > > > > 240 ohm 1w r/w 1.8k-1w,C505 2200pf/50v r/w 1000pf/50v D504 1n4148. > > > > Decakit011 contains all 4 parts > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Q402 (h.o.t.) thermal runaway > > > > > > > > Add 33 ohm 1/4w resistor across Q402 Base to emitter > > > > > > > > --------------------------------------------------------------- > > > > > > > > DAEWOO DTQ26S1FC > > > > > > > > Regulator problems > > > > > > > > Robert Ford > > > > > > > > check parts out of ckt: R818 .33-1w, R806 390k-1/2w, R812 100-1/4w, > > > > Q805,Q803,Q804. to test remove Q402 (hot) and put 120v 25w bulb across > > the > > > > 103vdc supply > > > > > > > > --------------------------------------------------------------- > > > > > > > > Bob Waterman, CET® #RI-28 > > > > Master Technician License #9109 > > > > Service Manager / Parts Manager > > > > Gemini Computer, TV, & Security Alarms > > > > (508)695-7302 > > > > (508)695-7769 FAX > > > > geminitv@xxxxxxxxxxxxxxxx > > > > geminitv@xxxxxxx > > > > www.geminicomputertvsecurityalarms.com > > > > > > > > > > > > ----- Original Message ----- > > > > From: "Advanced Electronics" <satguy@xxxxxxxxxxxxx> > > > > To: "tec" <techassist@xxxxxxxxxxxxx> > > > > Sent: Friday, October 03, 2003 6:29 PM > > > > Subject: [TechAssist] Curtis Mathis CM27101S burt resistors > > > > > > > > > > > > > I have this Curtis Mathis tv that has an RCA picture tube and what > > looks > > > > > like a Daweo Chassis the only numbers on the chassis are s/n > > > 4859812791-03 > > > > > and on a sticker on the chassis is MPGT18E528-1DTQ-29S3FC. What I > need > > > to > > > > > start with is the values of R812 and R828. > > > > > > > > > > Shaun > > > > > > > > > > Advanced Electronics > > > > > 224 West Riverview Ave. > > > > > Fort Morgan, CO 80701 > > > > > > > > > > satguy@xxxxxxxxxxxxx > > > > > > > > > > > > > > > > > > > > **************************************************************************** > > > > * > > > > > Classifieds! Buy or Sell! > > > > > http://sell.tech-assist.org > > > > > The Tech Address Book: > > > > > http://www.tech-assist.org/secure/tip/contact.htm > > > > > Add a Repair Tip Here, or Change/Remove your Email Address: > > > > > http://www.tech-assist.org/secure/tip/main.htm > > > > > Lost Password: > > > > > http://www.tech-assist.org and select "Lost your Login Info?". > > > > > Email Archives: > > > > > //www.freelists.org/archives/techassist/ > > > > > > > > > > > > > > > > > > > **************************************************************************** > > > * > > > > Classifieds! Buy or Sell! > > > > http://sell.tech-assist.org > > > > The Tech Address Book: > > > > http://www.tech-assist.org/secure/tip/contact.htm > > > > Add a Repair Tip Here, or Change/Remove your Email Address: > > > > http://www.tech-assist.org/secure/tip/main.htm > > > > Lost Password: > > > > http://www.tech-assist.org and select "Lost your Login Info?". > > > > Email Archives: > > > > //www.freelists.org/archives/techassist/ > > > > > > > > **************************************************************************** > * > > Classifieds! Buy or Sell! > > http://sell.tech-assist.org > > The Tech Address Book: > > http://www.tech-assist.org/secure/tip/contact.htm > > Add a Repair Tip Here, or Change/Remove your Email Address: > > http://www.tech-assist.org/secure/tip/main.htm > > Lost Password: > > http://www.tech-assist.org and select "Lost your Login Info?". > > Email Archives: > > //www.freelists.org/archives/techassist/ > > **************************************************************************** * > Classifieds! Buy or Sell! > http://sell.tech-assist.org > The Tech Address Book: > http://www.tech-assist.org/secure/tip/contact.htm > Add a Repair Tip Here, or Change/Remove your Email Address: > http://www.tech-assist.org/secure/tip/main.htm > Lost Password: > http://www.tech-assist.org and select "Lost your Login Info?". > Email Archives: > //www.freelists.org/archives/techassist/ ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/