Try replacing L512.VCC for Q505 is supply from D512 through L512 to R571 to Q505. Hope it help's. Panday From: "Larry E." <videotech@xxxxxxxxxxxx> >Reply-To: techassist@xxxxxxxxxxxxx >To: techassist@xxxxxxxxxxxxx >Subject: [TechAssist] Re: Sony KV32HSR10 ANU-1 chassis pincushion headache >Date: Fri, 03 May 2002 16:01:56 -0400 > > >Terry, not real familiar with this unit, can I run this set with the >yoke plug removed? to see if my overheat problem >goes away, Larry E. > >Terry H. wrote: > > >I'm sure you've thought of it Larry, but I wouldn't put the yoke above > >suspicion. Since I own that same set, I hope not, but I did encounter one > >TX10 that caused that same symptom then would eat the HOT after it heated > >up. Just a thought. > >Terry H. > >----- Original Message ----- > >From: "Larry E." <videotech@xxxxxxxxxxxx> > >To: <techassist@xxxxxxxxxxxxx> > >Sent: Friday, May 03, 2002 12:40 PM > >Subject: [TechAssist] Sony KV32HSR10 ANU-1 chassis pincushion headache > > > > > >>Hi all, this sony has severe pincushion problem, R571, Q505, C535, > >>C548, D508 have all been changed, > >>Q504, D506, D507 check good as do all voltages on pincushion IC,531. > >>Problem is R571 and Q505 are still > >>running extremely hot, voltage on collector of Q505 reads -7.2v > >>schematic calls for +14.3?? collector of Q504 reads positive 9v, > >>schematic says -9v, I noticed that schematic says emitter of Q505 should > >>be +16 and that has to be a mis > >>print so I`m a little skeptical of this print, can`t run set more than a > >>minute or two because of heat problem, any > >>ideas?? TIA > >>Larry E. > >>American TV & Electronics > >>Sunny Florida > >> > >> > >> > >>------------------------------------------ > >>To REMOVE your email address, click here: > >> http://www.tech-assist.org/unsubb.html > >>------------------------------------------ > >>***NEW*** Tips Added Instantly!!!*** > >>Submit Repair Tips here: > >>http://www.tech-assist.org/secure/tip/ > >> > > > > > >------------------------------------------ > >To REMOVE your email address, click here: > > http://www.tech-assist.org/unsubb.html > >------------------------------------------ > >***NEW*** Tips Added Instantly!!!*** > >Submit Repair Tips here: > >http://www.tech-assist.org/secure/tip/ > > > > > > >------------------------------------------ >To REMOVE your email address, click here: > http://www.tech-assist.org/unsubb.html >------------------------------------------ >***NEW*** Tips Added Instantly!!!*** >Submit Repair Tips here: >http://www.tech-assist.org/secure/tip/ _________________________________________________________________ Send and receive Hotmail on your mobile device: http://mobile.msn.com ------------------------------------------ To REMOVE your email address, click here: http://www.tech-assist.org/unsubb.html ------------------------------------------ ***NEW*** Tips Added Instantly!!!*** Submit Repair Tips here: http://www.tech-assist.org/secure/tip/