Check c609 ,610,611,612,film caps.( they can be a real pain in the)... Also check vdr601,d648 150v zener. Might be a bad horiz. Dr. xformer ! Bill Sonora,Calif. "Bob@bobsTV" <woodman17@xxxxxxxxxxx> wrote: Phil, Had a Sony and found a .47 cap at drive transformer cause your exact symptom.. Bob. Bob's TV Worcester, ma woodman17@xxxxxxxxxxx ----- Original Message ----- From: "Phil Bader" To: Sent: Monday, June 27, 2005 4:44 PM Subject: [TechAssist] Re: Sony KV-32S25 dead, G-board Q601,Q602, HOT shorted. shorts again > Note on the 2sc4834's. > The originals were a suffix "N". > Glen at ACME assured me he sells the "P" suffix (2sc4834P) and are a > much heavier duty transistor than the orig. They sell a $6.95 kit of the > two PS transistors, HOT and .1 ohm resistor. I think the generac HOT and > maybe an electrolytic is the cause for the HOT overheating. I would > think a bad fly would have zapped it at once, not slowely heat it. > Will advise. Please send me feedback. > Phil > > Philip Bader > Jan Phyl TV Inc. (estab. 1976) > 3420 Recker Hwy. Winter Haven, Fl. 33880 > Fax (863) 299-8821 > email: tjanphyl@xxxxxxxxxxxxxxx > > > > Phil Bader wrote: > > >This was the typical G-Board power supply/ HOT/ drive transformer pins > >soldering fix: > >Q601,Q602 (2SC4834) R607 (.1 ohm 1w) and a shorted HOT Q502 2SC5148. A > >very visable bad solder driver transformer as always. Replaced the G > >board parts and HOT. Resoldered H. drive transformer of the ring cracks. > >Well it came up beautifully and ran OK for 5 minutes. I noticed the HOT > >was heating up pretty fast but the two PS transistors were cool.( I used > >two of Acme's high quality 2SC4834P transistors.) I think they were not > >the issue here. The HOT was a generac but same number. I feel the > >overheated HOT took itself and the new PS transistors out.Dead > >again,same parts. Is there certain lytics in the drive circuit in these > >models like others (hi ESR,etc) and which ones? I walked away and before > >I could get back to it, it went dead. Maybe 5 minutes. > >Phil Bader > > > > > > > -------------------------------------------------------------------------- --- > This Email List is Public. Remove: http://www.tech-assist.org/remove.htm > Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > Lost Password: http://www.tech-assist.org and select "Login Problems?". > Email Archives: //www.freelists.org/archives/techassist/ > ----------------------------------------------------------------------------- This Email List is Public. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/ Carol Rundle brundle@xxxxxxxxxxxxx ----------------------------------------------------------------------------- This Email List is Public. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/