I do! Assuming you eliminated the basics: flex board for connections, clean the speaker switch on rear,etc. Phil ----- Original Message ----- From: Kevin's TV Repair <kevintv@xxxxxxx> Date: Saturday, July 2, 2005 3:30 pm Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main module, volume cuts out. > Yes mine has the wings. Do you guys think it is the IC that is at > fault? > > Kevin Wilks > Kevin's TV Repair > Penticton BC Canada > kevintv@xxxxxxx > > > -----Original Message----- > From: techassist-bounce@xxxxxxxxxxxxx > [mailto:techassist-bounce@xxxxxxxxxxxxx] On Behalf Of al m > Sent: Saturday, July 02, 2005 6:41 AM > To: techassist@xxxxxxxxxxxxx > Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main module, > volume cuts out. > > Can't see the # on this but if it has the wings I have 1 too. > Al Marquardt > ampm@xxxxxxx > Al Marquardt Electronic Repair > 206 W Main > Girardville Pa. 17935 > ----- Original Message ----- > From: "Phil Bader" <tjanphyl@xxxxxxxxxxxxxxx> > To: <techassist@xxxxxxxxxxxxx> > Sent: Saturday, July 02, 2005 9:32 AM > Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main module, > volume > cuts out. > > > > Kevin, is your audio output the one with the "wings" as a heat > sink on > > top, part of the chip? Part# starts with an "A"? I may have one. > Check. > > Phil > > > > Philip Bader > > Jan Phyl TV Inc. (estab. 1976) > > 3420 Recker Hwy. Winter Haven, Fl. 33880 > > Fax (863) 299-8821 > > email: tjanphyl@xxxxxxxxxxxxxxx > > > > > > > > Kevin's TV Repair wrote: > > > >>I have been so busy I haven't been able to get back to this dog. > I > >>still may need the Audio IC, but I don't know. Right now the audio > >>works 95% of the time and the only way to get it to come back on > whenit > >>does fail is to turn the volume up a little. > >> > >>Kevin Wilks > >>Kevin's TV Repair > >>Penticton BC Canada > >>kevintv@xxxxxxx > >> > >> > >>-----Original Message----- > >>From: techassist-bounce@xxxxxxxxxxxxx > >>[mailto:techassist-bounce@xxxxxxxxxxxxx] On Behalf Of Bob@bobsTV > >>Sent: Friday, July 01, 2005 6:27 AM > >>To: TechAsist M > >>Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main module, > >>volume cuts out. > >> > >>Kevin, > >> Am I to assume your all set on the Zenith and have no > need for > >>the > >>audio chip? > >>Bob. > >> > >>Bob's TV Worcester, ma > >> > >>woodman17@xxxxxxxxxxx > >> > >> > >> > >>----- Original Message ----- > >>From: "Bob@bobsTV" <woodman17@xxxxxxxxxxx> > >>To: <techassist@xxxxxxxxxxxxx> > >>Sent: Monday, June 27, 2005 9:19 AM > >>Subject: Re: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main > module, > >>volume cuts out. > >> > >> > >> > >> > >>>Kevin, > >>> Could not find model with that combo of modules.. But found > >>> > >>> > >>many > >> > >> > >>>notes about erratic speakers...I also found 2 of the audio chips > >>> > >>> > >>A9982-00 > >> > >> > >>>(stamped on heat sink) If you want one let me know I will send > it at > >>> > >>> > >>n/c... > >> > >> > >>>Bob. > >>> > >>>Bob's TV Worcester, ma > >>> > >>>woodman17@xxxxxxxxxxx > >>> > >>> > >>> > >>>----- Original Message ----- > >>>From: "Kevin's TV Repair" <kevintv@xxxxxxx> > >>>To: <techassist@xxxxxxxxxxxxx> > >>>Sent: Friday, June 24, 2005 6:08 PM > >>>Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main > module,>>> > >>> > >>volume > >> > >> > >>>cuts out. > >>> > >>> > >>> > >>> > >>>>I smacked it good everywhere. When I first got the set I whacked > >>>> > >>>> > >>the > >> > >> > >>>>side really hard and the volume came back. But now my problem is > >>>> > >>>> > >>the > >> > >> > >>>>set is working most of the time. The other modules are 175-2034, > >>>>9-246-01, 9-186-05. I can't find any other numbers after the > 9-181. > >>>>The audio IC is on the 9-181 module. I would like to repair this > >>>> > >>>> > >>set > >> > >> > >>>>because it has a very nice picture for an older TV. > >>>> > >>>>Kevin Wilks > >>>>Kevin's TV Repair > >>>>Penticton BC Canada > >>>>kevintv@xxxxxxx > >>>> > >>>> > >>>>-----Original Message----- > >>>>From: techassist-bounce@xxxxxxxxxxxxx > >>>>[mailto:techassist-bounce@xxxxxxxxxxxxx] On Behalf Of Bob@bobsTV > >>>>Sent: Friday, June 24, 2005 12:45 PM > >>>>To: techassist@xxxxxxxxxxxxx > >>>>Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main > module,>>>>volume cuts out. > >>>> > >>>>Do you have other module numbers? That 9-181 had so many > variations>>>>01 > >>>>thru 18 if I remember.. Some of those sets did not even use the > >>>> > >>>> > >>audio on > >> > >> > >>>>the > >>>>9-181.. Before you spin your wheels sub another speaker.. Had > an old > >>>> > >>>> > >>RCA > >> > >> > >>>>that the sound went off but turning sound way up it returned... > >>>> > >>>> > >>Voice > >> > >> > >>>>coil > >>>>would catch on the magnet at regular volume but turning up > sound it > >>>>released. > >>>>Bob. > >>>> > >>>>Bob's TV Worcester, ma > >>>> > >>>>woodman17@xxxxxxxxxxx > >>>> > >>>> > >>>> > >>>>----- Original Message ----- > >>>>From: "Kevin's TV Repair" <kevintv@xxxxxxx> > >>>>To: <techassist@xxxxxxxxxxxxx> > >>>>Sent: Friday, June 24, 2005 3:31 PM > >>>>Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main > module,>>>>volume > >>>>cuts out. > >>>> > >>>> > >>>> > >>>> > >>>>>Yes it does have a remote, but I can't find the model number on > >>>>> > >>>>> > >>the > >> > >> > >>>>bell > >>>> > >>>> > >>>>>of the crt. > >>>>> > >>>>>Kevin Wilks > >>>>>Kevin's TV Repair > >>>>>Penticton BC Canada > >>>>>kevintv@xxxxxxx > >>>>> > >>>>> > >>>>>-----Original Message----- > >>>>>From: techassist-bounce@xxxxxxxxxxxxx > >>>>>[mailto:techassist-bounce@xxxxxxxxxxxxx] On Behalf Of Bob@bobsTV > >>>>>Sent: Friday, June 24, 2005 12:17 PM > >>>>>To: techassist@xxxxxxxxxxxxx > >>>>>Subject: [TechAssist] Re: Zenith 20", 1983 model, 9-181 main > >>>>> > >>>>> > >>module, > >> > >> > >>>>>volume cuts out. > >>>>> > >>>>>Is this a remote set? There may be a model number sticker on the > >>>>> > >>>>> > >>bell > >> > >> > >>>>of > >>>> > >>>> > >>>>>crt.. > >>>>>Bob. > >>>>> > >>>>>Bob's TV Worcester, ma > >>>>> > >>>>>woodman17@xxxxxxxxxxx > >>>>> > >>>>> > >>>>> > >>>>>----- Original Message ----- > >>>>>From: "Kevin's TV Repair" <kevintv@xxxxxxx> > >>>>>To: <techassist@xxxxxxxxxxxxx> > >>>>>Sent: Friday, June 24, 2005 3:10 PM > >>>>>Subject: [TechAssist] Zenith 20", 1983 model, 9-181 main module, > >>>>> > >>>>> > >>>>volume > >>>> > >>>> > >>>>>cuts > >>>>>out. > >>>>> > >>>>> > >>>>> > >>>>> > >>>>>>Sorry I don't have the model number for this one. The volume > >>>>>> > >>>>>> > >>will > >> > >> > >>>>>>disappear after several minutes or hours and no amount of > >>>>>> > >>>>>> > >>tapping or > >> > >> > >>>>>>banging will bring back the sound. If I raise the volume it > >>>>>> > >>>>>> > >>will > >> > >> > >>>>>>finally come back on again. I inspected the sound circuit for > >>>>>> > >>>>>> > >>cold > >> > >> > >>>>>>solders and found none. Any other ideas on this oldie but > >>>>>> > >>>>>> > >>goodie? > >> > >> > >>>>>>Kevin Wilks > >>>>>>Kevin's TV Repair > >>>>>>Penticton BC Canada > >>>>>>kevintv@xxxxxxx > >>>>>> > >>>>>> > >>>>>> > >>>>>> > >>>>>> > >>>>>> > >>----------------------------------------------------------------- > ----- > -- > >> > >> > >>>>>-- > >>>>>--- > >>>>> > >>>>> > >>>>>>This Email List is Public. Remove: > >>>>>> > >>>>>> > >>>>>http://www.tech-assist.org/remove.htm > >>>>> > >>>>> > >>>>>>Set Vacation > >>>>>> > >>>>>> > >>>>>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>>>> > >>>>> > >>>>>>Lost Password: http://www.tech-assist.org and select "Login > >>>>>> > >>>>>> > >>>>>Problems?". > >>>>> > >>>>> > >>>>>>Email Archives: //www.freelists.org/archives/techassist/ > >>>>>> > >>>>>> > >>>>>> > >>>>> > >>>>> > >>>>> > >>----------------------------------------------------------------- > ----- > -- > >> > >> > >>>>>----- > >>>>>This Email List is Public. Remove: > >>>>> > >>>>> > >>>>http://www.tech-assist.org/remove.htm > >>>> > >>>> > >>>>>Set Vacation > >>>>>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>>>>Lost Password: http://www.tech-assist.org and select "Login > >>>>> > >>>>> > >>>>Problems?". > >>>> > >>>> > >>>>>Email Archives: //www.freelists.org/archives/techassist/ > >>>>> > >>>>> > >>>>> > >>>>> > >>----------------------------------------------------------------- > ----- > -- > >> > >> > >>>>-- > >>>>--- > >>>> > >>>> > >>>>>This Email List is Public. Remove: > >>>>> > >>>>> > >>>>http://www.tech-assist.org/remove.htm > >>>> > >>>> > >>>>>Set Vacation > >>>>> > >>>>> > >>>>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>>> > >>>> > >>>>>Lost Password: http://www.tech-assist.org and select "Login > >>>>> > >>>>> > >>>>Problems?". > >>>> > >>>> > >>>>>Email Archives: //www.freelists.org/archives/techassist/ > >>>>> > >>>>> > >>>>> > >>>> > >>>> > >>>> > >>----------------------------------------------------------------- > ----- > -- > >> > >> > >>>>----- > >>>>This Email List is Public. Remove: > >>>> > >>>> > >>http://www.tech-assist.org/remove.htm > >> > >> > >>>>Set Vacation > >>>>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>>>Lost Password: http://www.tech-assist.org and select "Login > >>>> > >>>> > >>Problems?". > >> > >> > >>>>Email Archives: //www.freelists.org/archives/techassist/ > >>>> > >>>> > >>>> > >>> > >>> > >>----------------------------------------------------------------- > ----- > -- > >>-- > >> > >> > >>>--- > >>> > >>> > >>>>This Email List is Public. Remove: > >>>> > >>>> > >>http://www.tech-assist.org/remove.htm > >> > >> > >>>>Set Vacation > >>>> > >>>> > >>>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>> > >>> > >>>>Lost Password: http://www.tech-assist.org and select "Login > >>>> > >>>> > >>Problems?". > >> > >> > >>>>Email Archives: //www.freelists.org/archives/techassist/ > >>>> > >>>> > >>>> > >> > >> > >>----------------------------------------------------------------- > ----- > -- > >>----- > >>This Email List is Public. Remove: > http://www.tech-assist.org/remove.htm > >>Set Vacation > >>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>Lost Password: http://www.tech-assist.org and select "Login > Problems?". > >>Email Archives: //www.freelists.org/archives/techassist/ > >> > >>----------------------------------------------------------------- > ----- > ------- > >>This Email List is Public. Remove: > http://www.tech-assist.org/remove.htm > >>Set Vacation > >>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>Lost Password: http://www.tech-assist.org and select "Login > Problems?". > >>Email Archives: //www.freelists.org/archives/techassist/ > >> > >> > >> > >> > > > ------------------------------------------------------------------- > ----- > ----- > > This Email List is Public. Remove: > http://www.tech-assist.org/remove.htm > > Set Vacation > > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > > Lost Password: http://www.tech-assist.org and select "Login > Problems?". > > Email Archives: //www.freelists.org/archives/techassist/ > > > > > > > ------------------------------------------------------------------- > ----- > ----- > This Email List is Public. Remove: http://www.tech- > assist.org/remove.htmSet Vacation > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > Lost Password: http://www.tech-assist.org and select "Login > Problems?".Email Archives: > //www.freelists.org/archives/techassist/ > ------------------------------------------------------------------- > ---------- > This Email List is Public. Remove: http://www.tech- > assist.org/remove.htmSet Vacation > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacationLost Password: http://www.tech-assist.org and select "Login Problems?". > Email Archives: //www.freelists.org/archives/techassist/ > ----------------------------------------------------------------------------- This Email List is Public. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/