The Final culprits were a pair of 1 ohm resistors in parell at 3660 & 3661 making the final parts tally as follows 5630 FBT 7150 jungle Vert. IC (replaced as it was borrowed for an RCA) 3660 & 3661 1 ohm (parell resitors both open no sign of char or oxidation) Peter Oliver Tucson Radio TV From: "Intrepid Video Support" <support@xxxxxxxxxxxxxxxxxx> Reply-To: techassist@xxxxxxxxxxxxx To: <techassist@xxxxxxxxxxxxx> Subject: [TechAssist] Re: Philips TP3281C101 32D700-7570 shuts down post flyback Date: Sun, 19 Oct 2003 10:24:20 -0400 Peter, From Tech Repair CD: NAP\TP3281 D7\No turn On\Flyback popped taking out Jungle IC and other stuff. Many cases include loss of H drive and others may have loss of video. There are several different versions\of this chassis* so part numbers may vary. These are the most common parts that die when the flyback takes a dump... check them all when replacing flyback (IHVT).\D7\see D7 Link in this NAP table.\http://wa6ati.com/D7-DOC.pdf\\\\\\\ Magnavox\TP3281C101\Dead- indicator comes on clicks once\Good power supply voltages including the 130v supply\LED repeats a series of 4 short flashes and one long flash but the set is otherwise dead\32D700\When servicing either a D7 or G7 chassis the flybacks are a common failure\There are several components that also need to be checked as they can be damaged by the defective flyback\Ref# 3610 22K resistor part# 483511657706*Ref# 3331 47K resistor (SMD) part# 483511137445\Ref# 6328 Diode (SMD) part# 483513037095*Ref# 7325 Transistor (SMD) part# 532213060508\Ref# 7150 Signal IC - Note: replace with part number on IC (they depend on model)\\\\ Magnavox\TP3281C101\Dead set. The power LED may flash.\\\32D700\One possible cause is the flyback transformer(5630). First attempt to read the LED flashes\After the long on flash* count the *off* flashes. Use the Service Manual to look up the indicated fault\CAUTION: WITH AC POWER REMOVED FROM THE CHASSIS:\Examine the case of the flyback for bumps or bulges on the cylindrical part.\Any indication of expansion means the flyback is defective and must be changed.\When defective flyback is disc\\\ Jeff Dougherty Intrepid Video TV/VCR 263 S Front St Steelton PA 17113 fax...717-564-4952 www.intrepid-video.com www.tech-repair.net ----- Original Message ----- From: "Peter oliver" <oliver_peter1@xxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Saturday, October 18, 2003 5:06 PM Subject: [TechAssist] Philips TP3281C101 32D700-7570 shuts down post flyback Philips TP3281C101 32D700-7570 EMD782A001 Bad Flyback arced thru board from side of transformer to between jumper at 9397 and 5660/9660. Put in flyback # 3128 138 20623 can anyone verify this is correct, numbers on Transformers match 1st 2 lines. Checked the components listed on sheet with flyback and on the site with the D7.doc too. HAve replaced IC 7150 also. Problem now is that HV will usually fluxup for about 20 sec (just short of getting picture) then shutdown. (has anyone converted the 7570 manual/schematic to PDF yet off the force cd?) Peter OLiver Tucson Radio TV _________________________________________________________________ Cheer a special someone with a fun Halloween eCard from American Greetings! Go to http://www.msn.americangreetings.com/index_msn.pd?source=msne134 ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/ ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/ _________________________________________________________________ Surf and talk on the phone at the same time with broadband Internet access. Get high-speed for as low as $29.95/month (depending on the local service providers in your area). https://broadband.msn.com ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/