Don, go back and read the original post from Phil, he calls Q840 LM78MR05, I'll bet it is the 5 pin L78MR05 after all. How about it Phil? ************************************************** Jim Myers Since 1972 Telrad Electronic Services Co. Fort Wayne, IN 46815 ************************************************* ----- Original Message ----- From: "Jim Myers" <jr.myers@xxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Thursday, September 11, 2003 5:12 PM Subject: [TechAssist] Re: Toshibas, CF3566A,CF3572B,(TAC9190)shut down issues,fixes Oops! The 5 pin one with reset output is L78MR05, it is used extensively in Toshiba sets so I guess I just Ass-U-Me'd. Sorry, ************************************************** Jim Myers Since 1972 Telrad Electronic Services Co. Fort Wayne, IN 46815 ************************************************* ----- Original Message ----- From: <hartstv@xxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Thursday, September 11, 2003 5:02 PM Subject: [TechAssist] Re: Toshibas, CF3566A,CF3572B,(TAC9190)shut down issues,fixes Hi Jim,Are you sure the L78M05 is a 5 pin??I checked my NTE & Partsminder source & they all come up as 3 pin regs,ie NTE 960 or NTE 1960.............. Don of HARTS-TVCR-ASC 9 Robert St,Oromocto,NB,Canada,E2V3N2 Tel-506-357-9785,Fax-506-357-6010 hartstv@xxxxxxxxxxx ----- Original Message ----- From: "Jim Myers" <jr.myers@xxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Thursday, September 11, 2003 6:38 PM Subject: [TechAssist] Re: Toshibas, CF3566A,CF3572B,(TAC9190)shut down issues,fixes > I would suspect that the L78M05 was bad but not because of the 5v VCC output > being too high, rather that something was wrong with the reset output pin. > This is a 5 pin device and is used to reset the micro as well as supplying > the 5 volt VCC. > ************************************************** > Jim Myers > Since 1972 > Telrad Electronic Services Co. > Fort Wayne, IN 46815 > ************************************************* > ----- Original Message ----- > From: <hartstv@xxxxxxxxxxx> > To: <techassist@xxxxxxxxxxxxx> > Sent: Thursday, September 11, 2003 4:30 PM > Subject: [TechAssist] Re: Toshibas, CF3566A,CF3572B,(TAC9190)shut down > issues,fixes > > > Phil,Glad you got your 2 units repaired.I have a question on the Q840 reg > that you replaced.If it's 3/4 of a volt too hi this will cause shutdown or > intermittent startup?If it was low by this amount I would have replaced it > but hi by this amount I would have missed this as a fix.I know you also > replaced a filter;but I'm just curious as to how you knew to replace the 5 > volt reg.I would assume with the plus & minus tolerance of my meter & the 5 > volt reg,a 3/4 volt difference high would be over looked.Not trying to be > pickey,very good t/sing on your part.The B+ for the micro's on these units > must be very critical........ > Don of HARTS-TVCR-ASC > 9 Robert St,Oromocto,NB,Canada,E2V3N2 > Tel-506-357-9785,Fax-506-357-6010 > hartstv@xxxxxxxxxxx > > > > ----- Original Message ----- > From: "Philip Bader" <tjanphyl@xxxxxxxxxxxxxxx> > To: <techassist@xxxxxxxxxxxxx> > Sent: Thursday, September 11, 2003 1:58 PM > Subject: [TechAssist] Toshibas, CF3566A,CF3572B,(TAC9190)shut down > issues,fixes > > > > Both 35" Toahibas in for shutting down intermittantly, getting > > progressively worse until one stayed dead. > > Both Chassis# TAC9190. > > One came to life replacing an open cap C871 (22mfd/50V) on the smps > > board. > > The other came up with the same C871 (22mf/50V) cap plus a regulator > > Q840 (LM78MR05) that was outputting about 5.75VDC on a pin that should > > have been a steady 5VDC Standby. Measure that output across the > > 100mfd@xxxx Cap C844. Near the LM78MR05 IC. > > Always ESR all caps,and solder good. > > The group helped a lot with these.Good group. > > Phil Bader > > -- > > Philip Bader > > Jan Phyl TV Inc. (estab. 1976) > > 3420 Recker Hwy. Winter Haven, Fl. 33880 > > Fax (863) 299-8821 > > email: tjanphyl@xxxxxxxxxxxxxxx > > For Professional Technicians Only > > > > > **************************************************************************** > * > > Classifieds! Buy or Sell! > > http://sell.tech-assist.org > > The Tech Address Book: > > http://www.tech-assist.org/secure/tip/contact.htm > > Add a Repair Tip Here, or Change/Remove your Email Address: > > http://www.tech-assist.org/secure/tip/main.htm > > Lost Password: > > http://www.tech-assist.org and select "Lost your Login Info?". > > Email Archives: > > //www.freelists.org/archives/techassist/ > > > > > **************************************************************************** > * > Classifieds! Buy or Sell! > http://sell.tech-assist.org > The Tech Address Book: > http://www.tech-assist.org/secure/tip/contact.htm > Add a Repair Tip Here, or Change/Remove your Email Address: > http://www.tech-assist.org/secure/tip/main.htm > Lost Password: > http://www.tech-assist.org and select "Lost your Login Info?". > Email Archives: > //www.freelists.org/archives/techassist/ > > **************************************************************************** * > Classifieds! Buy or Sell! > http://sell.tech-assist.org > The Tech Address Book: > http://www.tech-assist.org/secure/tip/contact.htm > Add a Repair Tip Here, or Change/Remove your Email Address: > http://www.tech-assist.org/secure/tip/main.htm > Lost Password: > http://www.tech-assist.org and select "Lost your Login Info?". > Email Archives: > //www.freelists.org/archives/techassist/ > **************************************************************************** * Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/ **************************************************************************** * Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/ ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/