Check the 12 volt supply to the relay drive circuit first. If that's okay then these are from WINSTIPS: --------------------------------------------------------------- Text pasted from WinSTIPS 2.0 http://www.ServiceSoftware.com --------------------------------------------------------------- SONY KP46S15 Press Pwr-Hv,Click-Click,Timer/Sandby Lght Blnks Twice,Shuts Dn Bruce A-1 Tv Van.Wa. 9/99 On E Brd Pull Cn802,If Starts;Ic 701,731,761=Vid.Drive=Tda6106 (all 3) No Start;Pull Cn624 On Pwr Brd,If Starts=Audio Out=Ic230=Tda7265 See Next Tip --------------------------------------------------------------- SONY KP46S15 Press Pwr-Hv,Click-Click,Timer/Sandby Lght Blnks Twice,Shuts Dn Cont: Bruce A-1 Tv Van.Wa. 9/99 If Still No Start;Remove 3 Anode Leads From Tripler(Push Down & Turn) Also Remove 3 Crt Brds If Starts Suspect Shorted Crt,To Ident;Remove 1 Anode Lead/Crt Brd At A Time. Note:Don't Remove Hv Xfrmr Lead At Trip. --------------------------------------------------------------- SONY KP46S15 Press Pwr-Hv,Click-Click,Timer/Sandby Lght Blnks Twice,Shuts Dn Cont: Bruce A-1 Tv Van.Wa. 9/99 No Start;D Brd=Conv.Pull Cn1757 If Starts,Chk Glass Fuses,If Either Open=Conv Ic=Stk392-010 If Fuses Ok Sus.Ic1803,04,07,08 B+ Reg Also Assoc.Filter Caps Poss.Leaky (See Next Tip) --------------------------------------------------------------- SONY KP46S15 Intermitent Dead Dan Mundy, Cet/Csm Ic 1102 9v Regulator On U Board Slow To Come Up After Set Had Been On For Some Time Causing Power Down To Trip. This Ic Is Not On Schematic And Takes The Place Of The 9v Line Supplied To That Board. --------------------------------------------------------------- SONY KP46S15 Dead Jnm D669 # 871991119 & C663 # 112694811 100/35v G Pcb --------------------------------------------------------------- SONY KP46S15 Dead. Loud Noise, Smoke, Then Dead With Blinking Led Bryn Mawr Tv Ic230 Shorted On A Cba (Tda7265) Q601, Q602 Shorted (2sc4834) D651 (D4sbs4-F) Open R606 (0.1 Ohm 1/2w Fusible) C667 (470uf/25v) On G Cba --------------------------------------------------------------- Bob Waterman, CET® #RI-28 Master Technician License #9109 Service Manager Gemini Computer, TV, & Security Alarms (508)695-7302 (508)695-7769 FAX geminitv@xxxxxxxxxxxxxxxx geminitv@xxxxxxx ----- Original Message ----- From: "Phil Bader" <philbad@xxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Thursday, October 17, 2002 11:19 AM Subject: [TechAssist] Sony PTV: KP46S15 instant shut down at turn on,P.S.cycles > > This 46 inch Sony will power up with HV, instantly shut down. > Disconnected the HV splitter block, no help.Same. The SMPS seems to > continue to cycle as if trying to come on. Helping a fellow tech. > Phil Bader > -- > Philip Bader > Jan Phyl TV Inc. (estab. 1976) > 3420 Recker Hwy. Winter Haven, Fl. 33880 > Fax (863) 299-8821 > email: philbad@xxxxxxxxxx > > ------------------------------------------ > To REMOVE your email address, click here: > http://www.tech-assist.org/unsubb.html > To CHANGE your email address, click here: > http://www.techassist.net/forms/change.html > ------------------------------------------ > ***NEW*** Tips Added Instantly!!!*** > Submit Repair Tips here: > http://www.tech-assist.org/secure/tip/ > ------------------------------------------ To REMOVE your email address, click here: http://www.tech-assist.org/unsubb.html To CHANGE your email address, click here: http://www.techassist.net/forms/change.html ------------------------------------------ ***NEW*** Tips Added Instantly!!!*** Submit Repair Tips here: http://www.tech-assist.org/secure/tip/