From the pix, looks like the same setup as the 140A Thanx, Gary - just what I need. Roger G. Mr. Fix-It Harrisburg, PA 17110 WebSite- http://mrfixit.netfirms.com rogerfixit@xxxxxxxx FAX 510-740-3641; Tel: 717-763-7098 (shop) 717-652-1703(home) At 10:41 AM 1/26/2005, you wrote: >Here is some info that will hopefully help. It is for KSS240A rather >than 140A though. > >included is a link to a photo of the KSS240A. > >http://www.number63.ca/KSS240A.jpg > > >----------------------------------------------------------------- > > >Hi Gary. > Try this : >-scope the RF wave form at pin 40 of Servo IC 101 CXA1372 ,usually it's >about 1 vpp to 1.2 vpp (good condition) .If it's under 1 Vpp ,the best way >is replace the pickup KSS 240A. >-you can make the pickup 's life last longer (several months) by increasing >the laser current . >-There are 3 trim pots on the KSS240A .The righthand is the laser curent >adjust,the middle is focus bias adj,and the lefthand is tracking offset adj. >-If the music still skipping ,you should increase the tracking gain trim pot >RV101 (on the BD board) a little (clockwise). > Hope this helps > >Vo Hung > >-------------------------------------------------------------------- >One way you could maybe Tell is place your DMM or Scope on each Pot by >tacking a short buss wire on it , then as you insert a CD , observe if the >DMM responds the same time with a reading as when the Red Laser turns on >and >is seen reflecting on the CD from a side view. > >I think there are (2) Pots for the Coils that raise / lower the Lense which >set focus limits, then one other will be the laser Power level. I would not >know 100% weather that is indeed so, but if the voltages on those 2 Pots >coincide when the Laser is focusing, I would say my guess was good. > >Steve Hearns >Technotronic Dimensions, NY [USA] >WWW.TECHNOTRONIC-DIMENSIONS.COM >1-877-817-9885 (Voice / Fax Toll Free - US Only) >E-Mail: Steve@xxxxxxxxxxxxxxxxxxxxxxxxxxx > >----- Original Message ----- >From: "Gary McCartney" <gary@xxxxxxxxxxx> >To: <techassist@xxxxxxxxxxxxx> >Sent: Friday, September 24, 2004 5:52 PM >Subject: [TechAssist] Sony CD laser assy KSS-240A, how to adjust gain? > > >I have a Sony CD player which plays most discs fine but a few sputter >before locking in and I'm thinking maybe just tweaking the gain on the >laser assembly would help. This one has 3 trim pots. Which ones do I >need to adjust, or is it a case where all 3 must be aligned and I >shouldn't attempt it? This part is $60.00 CDN at my supplier so I doubt >the customer would go for it. Probably cheaper at US sources but >exchange, brokerage fee, etc. might not be worth it? > >---------------------------------------------------------------------- > > >Gary McCartney > >McCartney Electronics >Guelph Ontario Canada >Est. 1984 >email: gary (at) number63.ca > > > > > > > > >Phil Bader wrote: > > Roger, I've searched /everywhere/. I can't find a manual, training > > manual,etc. No references to aligning it. No tips. Zippo. > > I guess try tritronics and do a search for the manual. I don't see any > > free sources out there.Sorry. > > Phil Bader > > > > Roger G wrote: > > > > > >>The model is STR-D159 (with the tape/cd part HST-d159). > >>Not sure they would give info on the laser pots but would be nice > >>thanx > >>Roger G. > >> > >>Mr. Fix-It > >>Harrisburg, PA 17110 WebSite- http://mrfixit.netfirms.com > >>rogerfixit@xxxxxxxx > >>FAX 510-740-3641; Tel: 717-763-7098 (shop) 717-652-1703(home) > >> > >>At 04:03 PM 1/24/2005, you wrote: > >> > >> > >> > >>>You gave the laser assy number, but if you can give me the model number > >>>I maybe can shoot you a manual if i locate one in PDF, or at least cut > >>>and paste the section you need. > >>>Phil Bader > >>> > >>>Roger G wrote: > >>> > >>> > >>> > >>> > >>>>Sony CD laser KSS-140A > >>>>This unit has 3 adjusting pots - most have only one. > >>>>Which one adjusts the laser output ? > >>>>(What do the other 2 do??) > >>>>Tried searching archives since I thought I read this but could not find > >>>>TIA > >>>> > >>>>Roger G. > >>>> > >>>>Mr. Fix-It > >>>>Harrisburg, PA 17110 WebSite- http://mrfixit.netfirms.com > >>>>rogerfixit@xxxxxxxx > >>>>FAX 510-740-3641; Tel: 717-763-7098 (shop) 717-652-1703(home) > >>>> > >>>> > >>>>---------------------------------------------------------------------- > --- > >>>> > >>>> > >>> > >>>---- > >>> > >>> > >>> > >>>>Lost Password: > >>>>http://www.tech-assist.org and select "Login Problems?". > >>>>Email Archives: > >>>>//www.freelists.org/archives/techassist/ > >>>> > >>>> > >>>> > >>>> > >>>> > >>>> > >>> > >>>-- > >>> > >>>Philip Bader > >>>Jan Phyl TV Inc. (estab. 1976) > >>>3420 Recker Hwy. Winter Haven, Fl. 33880 > >>>Fax (863) 299-8821 > >>>email: tjanphyl@xxxxxxxxxxxxxxx > >>> > >>> > >>> > >>>-- > >>>No virus found in this outgoing message. > >>>Checked by AVG Anti-Virus. > >>>Version: 7.0.300 / Virus Database: 265.7.2 - Release Date: 1/21/2005 > >>> > >>> > >>>----------------------------------------------------------------------- > ------ > >>>Lost Password: > >>>http://www.tech-assist.org and select "Login Problems?". > >>>Email Archives: > >>>//www.freelists.org/archives/techassist/ > >>> > >>> > >> > >> > >>------------------------------------------------------------------------ > ----- > >>Lost Password: > >>http://www.tech-assist.org and select "Login Problems?". > >>Email Archives: > >>//www.freelists.org/archives/techassist/ > >> > >> > >> > >> > > > > > > >----------------------------------------------------------------------------- >Lost Password: >http://www.tech-assist.org and select "Login Problems?". >Email Archives: >//www.freelists.org/archives/techassist/ ----------------------------------------------------------------------------- Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/