[TechAssist] Re: Sony 32" TV KV32XBR45, severe lines across screen, no video

  • From: "Shoreline Electronics" <jstielau@xxxxxxxx>
  • To: <techassist@xxxxxxxxxxxxx>
  • Date: Thu, 7 Nov 2002 09:51:16 -0500

Electronica has them for $9.99

1-800-722-5578

Jeff Stielau
Shoreline Electronics Repair
125 Beech Tree Lane
Westbrook, CT 06498
860-399-1861
860-664-3535 (fax)
jstielau@xxxxxxxx
----- Original Message -----
From: "Premium Technologies" <premtech@xxxxxxxxxxxxxx>
To: <techassist@xxxxxxxxxxxxx>
Sent: Thursday, November 07, 2002 3:41 AM
Subject: [TechAssist] Re: Sony 32" TV KV32XBR45, severe lines across screen,
no video


>
> Hi Gary,
> There are also tips from Sony Videotech that describe these same symptoms
> and point to replace IC301, P/N 8-752-063-50.
> The CXA1477AS is available for $49.90 at:
> http://www.electronicsic.com/Default.htm
> Hope this helps.
> Bill
>
> Premium Technologies
> 27501 V Street
> Ocean Park, WA. 98640
> Phone: (360) 665-5984
> Fax:     (815) 425-8530
> email: premtech@xxxxxxxxxxxxxx
> ----- Original Message -----
> From: "Gary McCartney" <gary@xxxxxxxxxxx>
> To: <techassist@xxxxxxxxxxxxx>
> Sent: Wednesday, November 06, 2002 8:05 AM
> Subject: [TechAssist] Sony 32" TV KV32XBR45, severe lines across screen,
no
> video
>
>
> >
> > I have here a Sony 32" TV KV32XBR45. The symptoms are:
> >
> > First turn it on, there are thin bright lines which go all the way
> > across the screen, and also cover the whole screen from top to bottom.
> > The spacing between each line is maybe 1/8 of an inch. after about 5
> > seconds, the lines dim out but can still be seen. There is no video
> > signal visible in the background. The background at this point is black.
> > Turning the G2 screen control up causes the lines to go brighter at
> > first but then they dim out to almost as dark as before G2 was adjusted.
> >
> > Scoping the R, G, B inputs to the CRT board shows sync but no video
> > information. Scoping heater waveform shows 23 V p-p from cold to warm
> > without fluctuation in amplitude. Measuring R, G, B pins on CRT I get
> > approx 185V dc on each. G1 measures zero V dc
> >
> > I have never worked on any of these XBR sets, but through reading tips,
> > I believe it could be one of 3 problems:
> >
> > -IK
> >
> > -caps bad in PIP module
> >
> > -bad jungle IC 301, CXA1477AS
> >
> >
> > I have gone over soldering on main and jungle IC boards, checked caps in
> > power supply and around IC 301 and changed a few marginal ones but there
> > is no difference in operation. I don't know where the PIP module is so I
> > haven't checked for caps there. There has to be a PIP module because it
> > is a dual tuner set. I also don't have schematic to make measurements
> > around the jungle IC or extension cables to make life easier to work at
> > it. I don't know much about the IK or how to check it out. Most of the
> > tips I read suggest the IC 301 jungle sounds like the probable suspect.
> > My supplier has it on back-order until December.
> >
> >
> > Any suggestions appreciated.
> >
> >
> >
> > --
> > ******* ATTENTION, PLEASE ********
> >
> > I have a new email address. Please
> > send all email in the future to:
> >
> > "Gary McCartney" <gary@xxxxxxxxxxx>
> >
> > Thanks.
> >
> > Gary McCartney
> >
> > McCartney Electronics
> > 7134 Fife Rd, RR 7
> > Guelph Ontario Canada N1H 6J4
> > Fax: (519)821-1530
> >
> > ------------------------------------------
> > To REMOVE your email address, click here:
> >   http://www.tech-assist.org/unsubb.html
> > To CHANGE your email address, click here:
> >   http://www.techassist.net/forms/change.html
> > ------------------------------------------
> > ***NEW*** Tips Added Instantly!!!***
> > Submit Repair Tips here:
> > http://www.tech-assist.org/secure/tip/
>
> ------------------------------------------
> To REMOVE your email address, click here:
>   http://www.tech-assist.org/unsubb.html
> To CHANGE your email address, click here:
>   http://www.techassist.net/forms/change.html
> ------------------------------------------
> ***NEW*** Tips Added Instantly!!!***
> Submit Repair Tips here:
> http://www.tech-assist.org/secure/tip/
>
>

------------------------------------------
To REMOVE your email address, click here:
  http://www.tech-assist.org/unsubb.html
To CHANGE your email address, click here:
  http://www.techassist.net/forms/change.html
------------------------------------------
***NEW*** Tips Added Instantly!!!***
Submit Repair Tips here: 
http://www.tech-assist.org/secure/tip/

Other related posts:

  1. Home
  2. techassist
  3. Archive
  4. 11-2002