Blue CRT magnet (neck)slipped out of alignment? Phil Bader Gary McCartney wrote: > > I have this RCA projection, chassis PKT169BNA lightbox in the shop. > (sorry I forgot to write down the TV model number). When customer showed > me the convergance setup with the white cross on screen, the blue was > way off, like 5 inches or more up and over to the left somewhat. This is > the first CTC169 proj. I have had a convergance problem with so I'm not > familiar with the circuits. I do have the manual though. > > I have pulled the main board with the convergance amp transistors on it > and found that Q7036 is bad. I had to grind out the charred area of the > pcb under Q7036 because it was black all the way through. Q7035 looked > heated too so that will also be replaced. R7122 (1 Ohm 1W) looked > stressed so I changed it, plus R7119 (2.2 Ohm 2W) was open. Haven't > found any sign of other defective parts. The plug P7016 to the blue > convergance yoke had got hot and deformed slightly at pin 1. I measured > the resistance of the yoke and compared it to the red yoke, and all > windings measure 1 ohm. > > Are there any other known suspect parts I should check out before I > order the transistors? > > I also question the wattage rating on some of the resistors. Example: > R7122 is rated 1W but it is the physical size of a normal 1/2 watt > resistor. R7119 is rated 2W but it is the same physical size as R7122 or > a normal 1/2 W resistor. I noticed some of the 1/4 W sized resistors are > rated 1/2W. What is up with these ratings? If I go to replace the 2W > resistor with another 2W from my stock, it will be twice or 3x the size > of the original. > > Thanks for any help. > -- > > Gary McCartney > > McCartney Electronics > Guelph Ontario Canada > Est. 1984 > email: gary (at) number63.ca > > ***************************************************************************** > Classifieds! Buy or Sell! > http://sell.tech-assist.org > The Tech Address Book: > http://www.tech-assist.org/secure/tip/contact.htm > Add a Repair Tip Here, or Change/Remove your Email Address: > http://www.tech-assist.org/secure/tip/main.htm > Lost Password: > http://www.tech-assist.org and select "Lost your Login Info?". > Email Archives: > //www.freelists.org/archives/techassist/ -- Philip Bader Jan Phyl TV Inc. (estab. 1976) 3420 Recker Hwy. Winter Haven, Fl. 33880 Fax (863) 299-8821 email: tjanphyl@xxxxxxxxxxxxxxx For Professional Technicians Only ***************************************************************************** Classifieds! Buy or Sell! http://sell.tech-assist.org The Tech Address Book: http://www.tech-assist.org/secure/tip/contact.htm Add a Repair Tip Here, or Change/Remove your Email Address: http://www.tech-assist.org/secure/tip/main.htm Lost Password: http://www.tech-assist.org and select "Lost your Login Info?". Email Archives: //www.freelists.org/archives/techassist/