VS4544 is a VZ3 chassis VS50502 is a VZ4 chassis Although made a year apart, it wouldn't surprise me the IHVT circuit design is similar. The transformer is part # 334P246010. Call CRC at (909) 629-5641 to get the IHVT. Damon B Telrad Electronics Fort Wayne IN ----- Original Message ----- From: "Tri-County Tv" <tricountytv@xxxxxxxxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Tuesday, January 24, 2006 12:46 PM Subject: [TechAssist] Re: Need VS-4544 schematic > Peggs, > Is there anyway to find out if the VS-4544 is same VS-50502 > except for screen size or at least the power supply board might be the same? > Tom Berger > Tri-County TV > Robbinsville > North Carolina 28771 > Ph--828-479-6043 > Fax-828-479-4868 > (tricountytv@xxxxxxxxxxxxx) > ----- Original Message ----- > From: "peggs" <peggs@xxxxxxxxxxxxx> > To: <techassist@xxxxxxxxxxxxx>; <techassist@xxxxxxxxxxxxx> > Sent: Tuesday, January 24, 2006 1:46 PM > Subject: [TechAssist] Re: Need VS-4544 schematic > > > > Mine DOES have the Focus lead,at an angle,out of the side of the Fly. > > Got mine from Tritronics $50ish. > > BTW,one side(pin 8 of the fly circuitry) of R5A28 had -114v on it,the > > other > > side was MUCH lower,thus it was overheating.These voltage readings were > > only there for an instant(shutdown),so MY resistor was just overheated,not > > open or increased in Value. I replaced it anyway.Check those Diodes out of > > circuit. > > The PS Secondary voltages were ALL a little low before shutdown. > > > > Peggs > > > > > > At 07:35 AM 1/24/06, Tri-County Tv wrote: > >>Peggs, > >> I think my fly is bad also as my set acts exactly as yours did > >> and > >>I'll bet these 2 models are similar. My fly # IS 334P24681 or 334P246B1 > >>can't tell if that 8 is a B or an 8. Did your fly have the focus lead > >>sticking out from the side at an angle? I did check those small diodes and > >>other resistors and all are ok. My burned R5A28 has red at one end and > >>purple at the other end, so it is possible my resistor could be 2.4K as > >>yours was. I have not started searching for this fly, where did you get > >>yours? > >>Tom Berger > >>Tri-County TV > >>Robbinsville > >>North Carolina 28771 > >>Ph--828-479-6043 > >>Fax-828-479-4868 > >>(tricountytv@xxxxxxxxxxxxx) > >>----- Original Message ----- > >>From: "peggs" <peggs@xxxxxxxxxxxxx> > >>To: <techassist@xxxxxxxxxxxxx>; <techassist@xxxxxxxxxxxxx> > >>Sent: Tuesday, January 24, 2006 11:55 AM > >>Subject: [TechAssist] Re: Need VS-4544 schematic > >> > >> > >> >I just repaired a VS50502 with an overheated R5a28(2.4K). > >> > The Flyback was bad.... it rang good..... set was shutting down > >> > immmediately.I could lift the 130v fuse,and the set would stay > >> > on(careful,slow discharge this 130v when you shut the set off). > >> > Found a few tips on this model for a couple of bad Diodes(1n4148) when > >> > R5a28 is bad........ D5a21,22. > >> > The Diodes were good in my set. > >> > > >> > I'm not sure how similar your set is to this one. > >> > > >> > Peggs > >> > > >> > > >> > At 03:11 PM 1/23/06, Tri-County Tv wrote: > >> >>Jeff, > >> >> I have scoped the H.O.T collector and looks distorted , driver > >> >>transistor output is clean , If I keep turning the set on , R5A28 > >> >>starts > >> >>to > >> >>burn, with is off the ACL line from flyback pin# 8 . I am not sure of > >> >>the > >> >>value of this resistor. It now measures about 65K. If pin 8 is the low > >> >>side > >> >>of the internal HV diodes , then maybe I am dealing with a bad fly. I > >> >>think > >> >>the burning of R5A28 should be clear clue as to where the problem is. I > >> >>am > >> >>still working without a schematic. > >> >>Tom Berger > >> >>Tri-County TV > >> >>Robbinsville > >> >>North Carolina 28771 > >> >>Ph--828-479-6043 > >> >>Fax-828-479-4868 > >> >>(tricountytv@xxxxxxxxxxxxx) > >> >>----- Original Message ----- > >> >>From: "Shoreline Electronics" <jstielau@xxxxxxxx> > >> >>To: <techassist@xxxxxxxxxxxxx> > >> >>Sent: Monday, January 23, 2006 12:27 PM > >> >>Subject: [TechAssist] Re: Need VS-4544 schematic > >> >> > >> >> > >> >> > Can you scope the collector at startup and see if the pulse is clean > >> >> > or > >> >> > distorted? > >> >> > > >> >> > Keep in mind , these sets have a discrete Horizontal Output section > >> >> > and > >> >> > a > >> >> > HV > >> >> > section. > >> >> > > >> >> > ========================== > >> >> > Jeff Stielau > >> >> > Shoreline Electronics Repair > >> >> > 344 East Main Street > >> >> > Clinton,CT 06413 > >> >> > 860-399-1861 > >> >> > 860-664-3535 (fax) > >> >> > jstielau@xxxxxxxx > >> >> > ======================== > >> >> > > >> >> > ----- Original Message ----- > >> >> > From: "Tri-County Tv" <tricountytv@xxxxxxxxxxxxx> > >> >> > To: <techassist@xxxxxxxxxxxxx> > >> >> > Sent: Monday, January 23, 2006 12:18 PM > >> >> > Subject: [TechAssist] Need VS-4544 schematic > >> >> > > >> >> > > >> >> >> Hello everybody, > >> >> >> I am in desperate need for a schematic and > >> >> >> any > >> >> >> repair tips for this old Mitsubishi Big screen. It shuts down at > >> >> >> turn > >> >> >> on, > >> >> >> and draws heavy current from H.O.T I suspect the flyback but it > >> >> >> rings > >> >> >> good > >> >> >> so maybe a shorted internal high voltage diode. I have a feeling > >> >> >> this > >> >> >> will > >> >> >> be very hard to find. I am ready to put a match to this dog! I > >> >> >> think > >> >> >> the > >> >> >> chassis is VZ3 Any help would be greatly appreciated. > >> >> >> Thomas Berger > >> >> >> Tri-County TV > >> >> >> Robbinsville > >> >> >> North Carolina 28771 > >> >> >> Ph--828-479-6043 > >> >> >> Fax-828-479-4868 > >> >> >> (tricountytv@xxxxxxxxxxxxx) > >> >> >> > >> >> > >> ------------------------------------------------------------------------- ---- > >> >> >> This Email List is accessible to the general public through search > >> >> >> engines. Remove: http://www.tech-assist.org/remove.htm > >> >> >> Set Vacation > >> >> >> mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >> >> >> Lost Password: http://www.tech-assist.org and select "Login > >> >> >> Problems?". > >> >> >> Email Archives: //www.freelists.org/archives/techassist/ > >> >> >> > >> >> > > >> >> > > >> >> > >> ------------------------------------------------------------------------- ---- > >> >> > This Email List is accessible to the general public through search > >> >> > engines. Remove: http://www.tech-assist.org/remove.htm > >> >> > Set Vacation > >> >> > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >> >> > Lost Password: http://www.tech-assist.org and select "Login > >> >> > Problems?". > >> >> > Email Archives: //www.freelists.org/archives/techassist/ > >> >> > >> >>------------------------------------------------------------------------ > >> ----- > >> >>This Email List is accessible to the general public through search > >> >>engines. Remove: http://www.tech-assist.org/remove.htm > >> >>Set Vacation > >> >>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >> >>Lost Password: http://www.tech-assist.org and select "Login > >> >>Problems?". > >> >>Email Archives: //www.freelists.org/archives/techassist/ > >> > > >> > > >> ------------------------------------------------------------------------- ---- > >> > This Email List is accessible to the general public through search > >> > engines. Remove: http://www.tech-assist.org/remove.htm > >> > Set Vacation > >> > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >> > Lost Password: http://www.tech-assist.org and select "Login > >> > Problems?". > >> > Email Archives: //www.freelists.org/archives/techassist/ > >> > >>-------------------------------------------------------------------------- --- > >>This Email List is accessible to the general public through search > >>engines. Remove: http://www.tech-assist.org/remove.htm > >>Set Vacation > >>mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > >>Lost Password: http://www.tech-assist.org and select "Login Problems?". > >>Email Archives: //www.freelists.org/archives/techassist/ > > > > -------------------------------------------------------------------------- --- > > This Email List is accessible to the general public through search > > engines. Remove: http://www.tech-assist.org/remove.htm > > Set Vacation > > mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > > Lost Password: http://www.tech-assist.org and select "Login Problems?". > > Email Archives: //www.freelists.org/archives/techassist/ > > -------------------------------------------------------------------------- --- > This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm > Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > Lost Password: http://www.tech-assist.org and select "Login Problems?". > Email Archives: //www.freelists.org/archives/techassist/ > ----------------------------------------------------------------------------- This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/