--------------------------------------------------------------- Text pasted from WinSTIPS 2.0 http://www.ServiceSoftware.com --------------------------------------------------------------- MITSUBISHI CS3515R Dead : Relay Click Only : Smps Not Running But Bas Raw B+ Feeding The Circuit Jeff Stielau : 12/9/03 : Shoreline Electronics Repair Open Trace From Cathode Of D904 To Pin5 Of Ic901 (Strs5141g) Caused By Corrosion From Leaking C914 (470uf 50v). You Can Test This Chassis Smps Power Supply On The Bench By Removing The Horizontal Output Transistor To Prevent Hv Developing. --------------------------------------------------------------- MITSUBISHI CS3515R Dead After `Lytic Replacement, Still No Turn On Palmetto Electronics, Inc. Check Front Control Pcb 4 H20/Liquid Spill Damage(Probably Due 2 Customer Cleaning Crt); Also Check D7x1, 3v 400/500mw Zener Diode 4 Lkg Or Short. --------------------------------------------------------------- MITSUBISHI CS3515R Dead Set <Common Problems> Palmetto Electronics, Inc. Don'T Waste Time 2 Check:Just Pull `Em & Change All That Show Signs Of Lkg Underneath:C921 2200uf/35v; C925 2200uf/50v; C926 1000uf/35v; C930 2200uf/35v (Mayb 50v In Some Units);C914 470uf/50v; C916 10uf/100v(Mayb Lo-Esr Type In Some Units{Larger Size Than Normal Is Key Here}); C965 2.2uf/200v(Mayb 250v In Some Units); C538 1uf/200v(Mayb 160v Or 250v In Some Units); C933 2200uf/25v; C935 220uf/10v(Mayb Another Of These Right Next 2 C935 In Some Sets); Inspect All Small `Lytics On Signal Pcb That U Can See(I.E., Standing Up Away From Pcb)4 Lkg Signs, As Well As Giving Pcb Close Visual Inspection 4 Electrolyte Lkg Around All `Lytics---Don'T 4 Get 2 Look On Both Sides Of Pcb! --------------------------------------------------------------- MITSUBISHI CS3515R Dead. Clicks At Turn On Joe Searles Tv Repair Virginia Beach, Va 23452 Replaced Open R960 (.33 Ohm 1w Resistor) --------------------------------------------------------------- MITSUBISHI CS3515R Dead. Relay Clicks John Kincaid Sos Tv Ic901 Strs5141 Bad All Caps/Res Check Good Sk Makes One --------------------------------------------------------------- MITSUBISHI CS3515R Dead. Relay Clicks Blue Ribbon Tv R903 Open 220k-1/8w --------------------------------------------------------------- MITSUBISHI CS3515R Power - shuts down Whitehall tv C916 10uf --------------------------------------------------------------- MITSUBISHI CS3515R Power - turn off intermittent, or flickering on & off Daves Tv C5h9 47/50. (measured 5 mfd). May have caused Q5h4 to fail --------------------------------------------------------------- MITSUBISHI CS3515R Power / Goes Dead After On Awhile Phil Hull After Spending Way To Much Time On This Unit And Replacing 8 Leaky Caps, I Found That The Power Relay K901 Would Unlatch Itself After It Was Hot. Replace K901 #278p049040 --------------------------------------------------------------- MITSUBISHI CS3515R Power Supply Int. Relay Chatter From Mitsubishi Intermittent Relay Chatter At Power Up.Check The Value Of C5h9 (47uf 50v) Located On The Defl/Pwr-Pcb. Pt#181p355080 --------------------------------------------------------------- MITSUBISHI CS3515R Power Supply No Power From Mitsubishi Relay Engages But No Start Up. Suspect Open L909. Located On Pcb-Def At Ic901 Pin 1. Pt# 411p012010 --------------------------------------------------------------- MITSUBISHI CS3515R Power Supply Shut Down At Power From Mitsubishi R956 May Have Opened Causing Current Limiter Q906 Bias To Be Incorrect. Located On Pcb-Def At Emitter Of Q906. (100k 1/2w) --------------------------------------------------------------- MITSUBISHI CS3515R Power Supply : Clicks On And Off Or Pulsing On/Off After Typical Recap Jeff Stielau : 8/31/05 : Shoreline Electronics Repair Q5h4 Leaky E-C Note : This Power Supply Can Be Bench Tested Easily. Remove The Horizontal Output And Clip A 100 Watt Bulb From The Collector Pad To Ground. Note : Using A 150w Bulb Will Cause The Chassis To Still Pulse As The Largere Bulb Will Draw Too Much Current. --------------------------------------------------------------- MITSUBISHI CS3515R Power Turns On/Off Repeatedly, Must Unplug Bryn Mawr Tv Replace Following Parts, Don'T Check C940 (22 Ufd 16 V Np) R956 (100k 1/4 W) C5h9 (47uf/50v) C5h8 (1uf/50v) --------------------------------------------------------------- MITSUBISHI CS3515R Power Up Relay Action No Snd/No Pix A-1 Tv Van.Wa. Solder T905 Main Pcb --------------------------------------------------------------- MITSUBISHI CS3515R Power up inop. in shutdown Meder's Tv Ic901, R903 increased in value, 2200, 1000uf in smps (4) --------------------------------------------------------------- MITSUBISHI CS3515R Power up inop. no relay click Larry Zukas R922 5.6k-1/2w in relay circuit --------------------------------------------------------------- MITSUBISHI CS3515R Power-Intermittent No Start-Up Palmetto Electronics Check 4 Poor Solder Connections @ All Pins Of "Ka" Connector. --------------------------------------------------------------- MITSUBISHI CS3515R Pulsing on/off Charlie C5h9, Q5h4, R5k7 --------------------------------------------------------------- MITSUBISHI CS3515R Relay Chatter At Power Up (Intermittant) C5h9 47uf/50v On Deflection / Pwr Board --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il Check C5h9 Between B&E Of Q5h4 [47 Mf 50v] In X-Protect Ckt On Defl Pcb --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) G5h4 Leaky --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il C940@ Q906 E/B Set Shuts Down At Start Up. Press On/Off Several Times In Sucession Set May Stay On For A Random Length Of Time. 22mf Bp 25v --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il Check C940 22mf 16v Between B&E Of Q906 In Current Lmitter Ckt On Defl Pcb --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il Check 130v Reg Line Check C914 [470mf 50v] Andd C916[10mf 100v] On Defl Pcb --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il Relay Engages But No Start Up Check L909 On Pcb-Def At Ic901 Pin1 Pt#411p012010 --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il Relay Engages But No Start Up Check L909 On Pcb-Def At Ic901 Pin1 Pt#411p012010 --------------------------------------------------------------- MITSUBISHI CS3515R Shutdown (Int) Earls Tv Naperville Il R956 May Have Opened Causing Current Limiter Q906 Bias To Be Incorrect Located On Pcb-Def At Emmiter Of Q906 [100k 1/2w --------------------------------------------------------------- Bob Waterman, CET® #RI-28 Master Technician License #9109 Service Manager / Parts Manager Gemini Computer, TV, & Security Alarms (508)695-7302 (508)695-7769 FAX geminitv@xxxxxxxxxxx ----- Original Message ----- From: <stumpy681@xxxxxxx> To: <techassist@xxxxxxxxxxxxx> Sent: Thursday, December 08, 2005 9:31 AM Subject: [TechAssist] Re: Mits CS3515R intermittent start up Thanks Eric, I cheched everything and it all looks good. It makes no sense. Any other suggestions? Anyone? TIA Dave Authorized Television and Electronic Services Smithfield, VA -----Original Message----- From: Eric Manuel <tvman@xxxxxxxxxxxxxxx> To: techassist@xxxxxxxxxxxxx Sent: Wed, 07 Dec 2005 17:43:22 -0330 Subject: [TechAssist] Re: Mits CS3515R intermittent start up Dave some tips to check out..Eric CS-3515R DEAD, RELAY CLICK ONLY. R922 5.6K OPEN AT Q902B..rb TELEVISION Mitsubishi CS3515R Intermittant Startup C5H9(47uf/50v), & sometimes damages D5H0 & D5G6 (both 33v zeners) CS3515R Dead, relay clicks no start Open R960 in power supply, .33ohm, off transformer secondary. mitsubishi cs3515r dead set c914 470mfd/50 power supply MITSUBISHI CS3515R NO POWER, GOES INTO SHUTDOWN REPLACE IC901, R903, AND THE 2200 AND 1000 UF'S IN SMPS TELEVISION MITSUBISHI CS3515R GOES INTO SHUTDOWN Q5H4 LEAKING Eric E M Electronics 59 Wights Rd Deer Lake NL Canada A8A 2J2 Ph# 709 635 2627 tvman@xxxxxxxxxxxxxxx stumpy681@xxxxxxx wrote: > > -I have a Mitsub. CS3515R that has very intermittent start up. It > intermittently powers up, Ive replaced at least 50 caps, Set has great > picture. Any help is really appreciated. > > TIA > Dave > Authorized Television and Electronis Services > Smithfield, VA > ------------------------------------------------------------------------- ---- > This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm > Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation > Lost Password: http://www.tech-assist.org and select "Login Problems?". > Email Archives: //www.freelists.org/archives/techassist/ > > ------------------------------------------------------------------------- ---- This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/ ---------------------------------------------------------------------------- - This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/ ----------------------------------------------------------------------------- This Email List is accessible to the general public through search engines. Remove: http://www.tech-assist.org/remove.htm Set Vacation mailto:ecartis@xxxxxxxxxxxxx?subject=set%20techassist%20vacation Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/