Thanks guys for the response. A special thanks goes to Jeff at Shoreline Electronics for the tip for IC900 (STRM6811). I had gone over this chassis using heat and freeze spray but missed this one. It was well hidden under the heatsink fins and covered up by two large elecrolytics (couldn't be seen unless you knew where to look). With the brightness at a minimum, the set would play for hours but as soon as I heated IC900 the set went into shutdown. New IC is on order. Again, thanks for the great tip. Daryl Daryl's TV 2402 Wyoming Ave. El Paso, TX 79903 915-565-9184 Voice/Fax daryls_tv@xxxxxxx www.angelfire.com/tv2/daryls_tv ----- Original Message ----- From: "Shoreline Electronics" <jstielau@xxxxxxxx> Date: Thu, 19 Aug 2004 13:53:20 -0400 To: <techassist@xxxxxxxxxxxxx> Subject: [TechAssist] Re: Mitsubishi, VS5043, Random shutdown > The second tip is your winner! Change the STRM IC > > --------------------------------------------------------------- > Text pasted from WinSTIPS 2.0 > http://www.ServiceSoftware.com > --------------------------------------------------------------- > > MITSUBISHI VS5043 > > Power Supply Intermittent Shutdown > > From Mitsubishi > > Replace L5a00,If Coil Is Wrapped In Black Tape,With Pt#351p138020, (The New > Coil Should Be Wrapped With Yellow Tape).This Is Located On The Main-Pcb. > > --------------------------------------------------------------- > > MITSUBISHI VS5043 > > Power Supply / Plays Awhile And Shuts Off / Intermittent > > Phil Hull > > Found A Defective Ic 900 Part # 267p129010 Str-M6811 > Found Problem With Coolant Spray > > --------------------------------------------------------------- > > > > ================================= > Jeff Stielau > Shoreline Electronics Repair > 344 East Main Street > Clinton,CT 06413 > (860)399-1861 > (860)664-3535 FAX > jstielau@xxxxxxxx > ================================= > ----- Original Message ----- > From: <daryls_tv@xxxxxxx> > To: <TechAssist@xxxxxxxxxxxxx> > Sent: Thursday, August 19, 2004 1:12 PM > Subject: [TechAssist] Mitsubishi, VS5043, Random shutdown > > > > > > I have a VS5043 Mitsubishi that has random shutdown. There isn't any flaw > in the picture to indicate what circuit to look in. It can shut down in a > couple of minutes or play all day. Checked for poor solder joints and found > very few bad. Tried heating and cooling and no help. ESR'd the caps and > didn't find any bad. However, I can lower the brightness no minimum and it > doesn't shutdown. I suspect an ABL or shutdown circuit problem but I have > no print to trace it out. I didn't find any tips with this type of problem. > > Any help or advice will be greatly appreciated. > > Daryl > > Daryl's TV > > 2402 Wyoming Ave. > > El Paso, TX 79903 > > 915-565-9184 Voice/Fax > > daryls_tv@xxxxxxx > > www.angelfire.com/tv2/daryls_tv > > > > > > -- > > ___________________________________________________________ > > Sign-up for Ads Free at Mail.com > > http://promo.mail.com/adsfreejump.htm > > > > > > -------------------------------------------------------------------------- > --- > > Lost Password: > > http://www.tech-assist.org and select "Login Problems?". > > Email Archives: > > //www.freelists.org/archives/techassist/ > > > > > ----------------------------------------------------------------------------- > Lost Password: > http://www.tech-assist.org and select "Login Problems?". > Email Archives: > //www.freelists.org/archives/techassist/ -- ___________________________________________________________ Sign-up for Ads Free at Mail.com http://promo.mail.com/adsfreejump.htm ----------------------------------------------------------------------------- Lost Password: http://www.tech-assist.org and select "Login Problems?". Email Archives: //www.freelists.org/archives/techassist/